Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2017 Hyundai Santa Fe Sport owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated that while driving at an undisclosed speed, the oil warning light illuminated and then turned off independently. The contact then stated that while driving at an undisclosed speed, the vehicle stalled. The contact was able to restart the vehicle. The vehicle was taken to the dealer where the contact was informed that the oil level was low, and a quart of oil was added. The contact then stated that on another occasion while driving at an undisclosed speed, the vehicle stalled without warning. The contact was able to restart the vehicle. The vehicle was then taken back to the dealer where another quart of oil was added. The contact was then advised by the dealer that an oil consumption test would be performed, and the contact was advised to drive the vehicle for 1,000 miles, and a tamper seal was placed on the vehicle. …
I am the current owner a 2017 Hyundai Santa Fe Sport. While I was driving my SUV on the highway at highway speeds at 60mph, the oil pressure and the check engine warning light illuminated all of sudden after around 1 hour of smooth ride. In the meantime, suddenly the vehicle lost motive power, the steering wheel seized and smoke came immediately. Losing motive power in running conditions and smoke coming out during failure could have endangered our lives. The smoke came out due to leakage of engine oil probably. The vehicle was stuck in the middle of the road. The vehicle was towed to the residence and then after Hyundai Dealership. The dealer was made aware of the failure. The failure mileage was approximately 76,245 only. …
My 2017 Hyundai Santa Fe had a new engine installed at the dealership, Fred Beans Hyundai Flemington, NJ. I picked it up on [redacted] on [redacted] (and after 134 miles) my car's check engine light came on. I rerouted to dealership about 8 miles. Sitting outside service bay, I smelled smoke and then saw smoke coming out of vents. I then jumped out of car and the car became engulfed in flames and subsequently exploded. The day I picked it up, I pointed out to the service manager that they had not reattached everything to the car properly, sloppy workmanship. Best guess is that they did not attach a valve correctly. Miracle no one was injured or killed!
I was driving my car and it showed no signs of any issue but the engine light came on and started blinking so I pulled over and got it towed to a mechanic. He told me that I would need a new engine that would cost me $8000. I looked into it and found that there was a defect with my vehicles engine and that if I took it to a dealership, I could possibly get it covered 100% so I did that and then they covered it and when I got the vehicle back, it had an issue every time I drove it where it was kind of speeding up and jerking when I drove it, I took it back after I told them what happened and then they told me that my catalytic converter was bad and needed to be replaced. I ended up paying $1500 to get that replaced and when I got the car back again it's still jerking and doing the same exact thing even worse. I contacted them. …
I have need to get 3 oil changes within the past month and a half. Twice I was told I was driving with no oil in my car and the engine was getting ready to go. I notice when I start my car in the morning it is making a rattling noise, this also happens when I try to accelerate and the car will get stuck in gear and hesitate before speeding up. It's been dangerous trying to drive on this highway. I also notice a thick white smoke coming from my muffler. I'm constantly paying for unnecessary oil changes and diagnostic from independent service centers and was told my motor is bad and causing all this oil consumption. I was told to contact Hyundai but no luck.
After my Hyundai dealership performed a recall on emissions my Santa Fe Sport started having problems on cold starts. After it has set for a few hours when I would put into gear and start to driving the car acted as though it was trying to flood out. I have to feather the accelerator and drive very carefully for at least 1/2 - 3/4 miles. This is very dangerous and make me very uncomfortable driving. I took my vehicle back to my Hyundai dealer and the mechanic told me they were waiting for a recall to the recall. How stupid!!! It has been over a month and nothing has been done to fix the problem. Please advise!
Check engine light came on to check the oil and I had recently had an oil change and all of a sudden within a week or two I needed to fill my oil back up and it's gone through two quarts of oil since my oil change this has been going on for 2 years I did not know there was some place like this where I could follow a complaint. I constantly put oil in my car because my car is constantly low on oil and there is no evidence of the oil leaking onto the ground whatsoever. I don't know where the oil is going to but it's not leaking on the ground and there's just been a constant issue for the past 2-3 years
My car is burning to much oil which has caused my car to have a check engine light. I was not due for an oil change until end of July 2023 and the car was barely with no oil. I took it in to get an oil change at Valvoline and they confirmed no oil was hardly in the chamber and that my car needed an oil consumption test by dealer. Hyundai models have been having multiple issues with engine failure. This is a safety Hazard as on the road is when I noticed my car shutting off on me. I am working on getting this taken care of with corporate Hyundai and dealer.
I purchased my vehicle at 51,700 miles. Approx 2 months ...1,000-2,000 miles later my car went into limp mode and wouldn't exceed 20 mph. I also noticed that my vehicle was consuming 4-qts of oil every 1,000 miles since then and is experiencing engine failure. It's a safety hazard to myself and others as the car just shuts off completely while driving. Hyundai won't do anything about it. I have documents to show every oil change/maintenance on vehicle.
I brought the car 4/2023 within 2 weeks I had to big it back brakes locking up replaced rotors and pads. Then the strut on right needed to be replaced because of noise and pulling, still pulls. Then the fuel pump went replaced that anc then the differential was replaced but still slipping. The oil light came in after the oil change had to add oil and requesting consumption test. I have had this car 6 months and nobody has figured out what's going on.
Fuel System complaints in other Santa Fe Sport years
Frequently asked questions
How common are fuel system problems on the 2017 Hyundai Santa Fe Sport?
NHTSA has 28 complaints about the fuel & propulsion system of the 2017 Hyundai Santa Fe Sport, 8% of the model year's 356 complaints.
Is there a recall for 2017 Hyundai Santa Fe Sport fuel system problems?
No. NHTSA lists no fuel & propulsion system recall for the 2017 Hyundai Santa Fe Sport, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2017 Hyundai Santa Fe Sport fuel system problems start?
Half of the complaints with a recorded mileage happened before about 22,000 miles, and 67% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 2 fires and 0 injuries to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.