Most common 2006 GMC Envoy problems
Share of the 436 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
GMC Envoy complaints by model year
Best Envoy years: 2001, 1999, 2009. Years to avoid: 2002, 2005, 2006, 2003, 2004. Compare all years →
2006 GMC Envoy recalls (8)
Visibility › Power window devices and controls
General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles.
Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015.
Exterior lighting › Headlights
General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles.
Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737.
Visibility › Power window devices and controls
General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles.
Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available.
Visibility › Power window devices and controls
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced.
Visibility › Power window devices and controls
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts,…
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available.
Air bags › Frontal
Certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. Testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction.
Remedy: Because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (GM) will repurchase these vehicles in accordance with the terms stated in GM's letter to…
Show 2 more recalls
Equipment › Other › Labels
Certain trucks and sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were shipped with tire and loading information labels listing an inacccurate vehicle capacity weight.
Remedy: Owners will be provided with corrected labels and installation instructions. At the customer's option, a dealer can install the label for them. The recall began on March 31, 2006.
Steering › Hydraulic power assist › Hose, piping, and connections
Certain passenger vehicles May have been built with a power steering hose that is not to specification. Under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose May fracture and leak fluid.
Remedy: Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. The recall will begin on October 14, 2005.
NHTSA defect investigations
Federal safety investigators have looked into 3 possible defects involving the 2006 GMC Envoy:
Loss of Headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV.
Driver's Master Power Window Switch
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New…
Fuel Level Gauge System Failure
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than…
What 2006 GMC Envoy owners say
Fuel & propulsion system all 207 →
The contact owns a 2006 GMC Envoy. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The failure occurred on three separate occasions. The vehicle was taken to an independent mechanic and diagnosed with fuel pump and fuel pump sensor failure. The fuel pump and fuel pump sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 270,319.
At every fillup we can smell gas like there is a fuel leak. I had a shop do a fog test and they confirmed a leak "somewhere from the top of the tank". The tank would need to be dropped to visually inspect at a cost of $400-$500 just for the dropping of the tank. Then there would be added costs to repair whatever is causing the leak and smell of gas. After hearing that I came home to start my searching for recalls & safety notices to find that GM had a notice issued as well as the NHTSA, but it seems they cut the year off at 2004 & 120,000 miles. According to the thread below, it appears this was extended to vehicle under 150,000 miles which we are well under, but we don't have a 2002-2004 model. …
Electrical system all 108 →
Went to drive home at night lights were working then all the sudden went out. Pulled over checked fuses n restarted auto and still no lights, the dash board lights were out as well. Safety of other drivers and my family were affected. Did have to have a friend come and get us. And went to get auto next day n still no lights. When got home checked everything agine and fuses were ok the wireing look all intact. Still no lights. Or dash lights.
Had problems with the heater's blower motor not blowing or sometimes blowing but not on every speed. Looked up issue on youtube and found many videos of the same issue and the videos showed them having to replace the heater's blower motor resister. As the resister was being replaced, we noticed the resister was melted onto the plug it plugs into and the thick red wire was also melted. Resister got replaced and the blower speeds all worked again. Shortly after installation of the new resister, the number 5 speed failed but all others continued. Three months later, the resister failed. Exchanged and replaced the resister again and worked on all speeds but 5 again. Had a smell to it while in use, we got use to it and thought nothing of it anymore. …
Lights all 56 →
The contact owns a 2006 GMC Envoy. The contact stated while driving at various speeds, the headlights would fail not allowing them to see anything while driving. The contact stated that the headlights would only engage using the high beams. The contact stated no warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with the headlight driver module needing to be replaced. The contact replaced the headlights but the failure still occurred. The contact was relating the failure to the NHTSA campaign number: 15V519000 (Exterior lighting). The manufacturer had not been informed of the failure. The failure mileage was approximately 90,000.
The contact owns a 2006 GMC Envoy. The contact stated while driving with the low beam headlights engaged, the low beams headlights failed to illuminate, causing a reduced visibility of the roadway. The contact engaged the high beam headlights and was able to continue driving. The contact stated that the failure had been recurring while driving. An unknown dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 15V519000 (Exterior Lighting). The manufacturer was notified of the failure. The failure mileage was unknown.
2006 GMC Envoy engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 5.3L 8-cyl | 4-speed automatic | RWD | 14 / 20 / 17 |
| 4.2L 6-cyl | 4-speed automatic | RWD | 14 / 20 / 16 |
| 4.2L 6-cyl | 4-speed automatic | 4WD/AWD | 14 / 20 / 16 |
| 5.3L 8-cyl | 4-speed automatic | 4WD/AWD | 14 / 20 / 16 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2006 GMC Envoy a good car?
Based on 436 owner complaints filed with NHTSA, the 2006 Envoy rates avoid: 5.3× as many complaints as a typical year of the Envoy at the same age. It is one of the Envoy years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2006 GMC Envoy?
The fuel & propulsion system — 207 complaints, 47% of all complaints for this model year, most often about storage › fuel gauge system. Next are the electrical system (108) and lights (56).
How many recalls does the 2006 GMC Envoy have?
There are 8 recalls for the 2006 GMC Envoy, the most recent from September 24, 2015 (power window devices and controls). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the GMC Envoy?
The best years by complaints, compared at the same age, are 2001, 1999 and 2009. Years to avoid or approach with caution: 2002, 2005, 2006, 2003 and 2004. See the full GMC Envoy years comparison.
At what mileage do 2006 GMC Envoy problems happen?
The median mileage reported in complaints is about 78,000 miles; 22% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.