Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 Ford Fusion owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2012 Ford Fusion. The contact stated that while starting the vehicle, the power steering assist fault message was displayed. The power steering function was inoperable. The check engine warning light was illuminated due to a possible canister purge valve failure. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 15V340000 (Steering). The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 165,461.
The contact owns a 2012 Ford Fusion. The contact stated while driving at high speeds the vehicle shut off, restarted, and shut off again. The contact was able to drive, but the vehicle shut off. The power steering assist fault warning light was illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed that the warranty had expired. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 160,000.
The contact owns a 2012 Ford Fusion. The contact stated that while driving under 35 MPH, the vehicle was shaking abnormally. The vehicle was shaking abnormally while idling as if the vehicle would shut off. The contact had replaced the battery 8 times; however, the failure persisted. While driving approximately 65 MPH and overtaking other vehicles, the check engine warning light began flashing temporarily. The failure had occurred twice. The vehicle was taken to the dealer who diagnosed the vehicle that the oil was leaking from the valve cover gasket, oil pan, and front seal and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was unknown.
The contact owns a 2012 Ford Fusion. The contact stated that while driving at various speeds, the vehicle lost motive power and hesitated upon depression of the accelerator pedal. Both the power train and check engine warning lights would appear on the instrument panel. The vehicle was taken to both an independent mechanic and a dealer but neither could diagnose to determine the cause of the failure. The manufacturer was not notified of the failure. The failure mileage was unknown.
My steering assist system goes of at odd times, and the acceleration it does tiny tugs, and my suspension it rattles, over street bumps,, can it be fixed by a dealership, cause it's my only vehicle I have and plus I'm on ssdi income and I can't afford major repairs, like these, and if so have the car fully inspected just in case I'm missing something, oh and also there's a popping noise coming from the front of the car..
2012 Ford Fusion is having issues similar to the Ford Focus recall, 18S32, that pertains to the canister purge valve and powertrain issue. Current fusion has a 2.5L motor in it. Have replaced the canister purge valve 3 times in a 2-year span and is currenting giving codes (as well as engine light being on) of another failure. Do believe it is affecting the powertrain as well, as it is jerks under workload.
Pulled out of a side street Taylor onto a main highway 39 beach Blvd and car jolted and didn't have much go. Seemed sluggish. Transmission mount bolt had snapped off and I could have been in a major accident because I had oncoming traffic coming at me when I merged into the street and lost power because of the incident.
Transmission issues. Jerks and shudders and loss of power, broken motor mounts, PCM issues, misfire issues and etc. Car threw codes, many expensive trips to Ford dealerships, excessive undriveable down time, unsafe to be on a highway or go up a hill when it shifts (automatic), 6F35 Transmission in my 2012 Ford Fusion
Their is a recall for Ford Abs Module yet their needs to be one for 2012 Ford Fusions Se as well I have paid over 3200 dollars for my brakes alone . I have had 2 near misses and was in an unreported incident today from power loss on my breaks . Very unsafe for me and those around
Vehicle loses power while driving, with no response when accelerator is depressed further. The engine continues to run but no throttle response. No engine warning light came on. No codes stored. Must stop, turn off engine and perform an engine restart to continue driving again.
NHTSA investigations
Electronic Throttle Body Malfunction
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles.
Engine complaints in other Fusion years
Frequently asked questions
How common are engine problems on the 2012 Ford Fusion?
NHTSA has 116 complaints about the engine & cooling of the 2012 Ford Fusion, 5% of the model year's 2,517 complaints.
Is there a recall for 2012 Ford Fusion engine problems?
No. NHTSA lists no engine & cooling recall for the 2012 Ford Fusion, though it has 5 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 Ford Fusion engine problems start?
Half of the complaints with a recorded mileage happened before about 52,000 miles, and 22% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 3 fires and 5 injuries to engine & cooling problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.