Most common 2006 Ford F-350 problems
Share of the 145 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford F-350 complaints by model year
Best F-350 years: 2009, 2007, 2013. Years to avoid: 1999, 2000, 1997. Compare all years →
2006 Ford F-350 recalls (1)
Exterior lighting › Brake lights
Ford is recalling certain model year 2011 ranger trucks built from January 25, 2011, through April 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250,…
Remedy: Dealers will replace the switches free of charge. The safety recall began on August 15, 2011. Owners May contact Ford motor company customer relationship center at 1-866-436-7332.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2006 Ford F-350:
Violent front end oscillation
Odi has received 78 consumer complaints of severe suspension and steering wheel shimmy and oscillations commencing after the subject vehicles traveled over an uneven road surface. The majority of these incidents occurred at speeds of 50 MPH or greater.thirteen of the complaints received by odi allege loss of steering control and that the vehicle changed driving lanes uncontrollably.four of the complaints received by…
Violent front end oscillation
This investigation was opened based on 78 consumer complaints of severe suspension and steering wheel oscillations after the subject vehicles traveled over an uneven surface.odi was concerned about these complaints because many of them alleged loss of control and the loss of control occurredat speeds above 50 miles per hour.at the time these complaints were received, odi was also aware of the TSB 07-10-10 and early…
What 2006 Ford F-350 owners say
Steering all 51 →
The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower speed to allow the shimmy to self-correct. There was no warning illuminated. The contact had taken the vehicle to an independent mechanic to be diagnosed; however, no cause for the failure was found and the failure was not duplicated. The vehicle was not repaired. The mechanic checked for recalls related to the failure and advised the contact that the manufacturer had issued a recall for the failure (09L02) for severe steering wheel and front wheel vibrations. The manufacturer was not informed of the failure. The failure mileage was approximately 265,000.
My truck experiences what I have learned is called the death wobble. The condition occurs intermittently but usually at speeds above 50mph and seems to be initiated by hitting any small bump. The whole front end shakes violently like the tires have been half filled with lead causing them to rotate wildly out of round. The truck actually bounces up and down rapidly and the steering wheel shakes violently creating a very unsafe driving circumstance. My research into this issue uncovered that this is a well-known condition that has been reported multiple times by many different Ford truck owners and that it occurs on Ford trucks of various year make and model. I also am aware of Fords service letter 09L02 advising owners to maintain proper air pressure to combat the issue. …
Suspension all 50 →
The contact owns a 2006 Ford F-350. The contact stated that while driving approximately 45 MPH, the front passenger wheel drove over a small dip in the roadway and the vehicle started to shimmy. The contact stated that the vehicle was difficult to steer. The contact continued driving at a slower speed to allow the shimmy to self-correct. There was no warning illuminated. The contact had taken the vehicle to an independent mechanic to be diagnosed; however, no cause for the failure was found and the failure was not duplicated. The vehicle was not repaired. The mechanic checked for recalls related to the failure and advised the contact that the manufacturer had issued a recall for the failure (09L02) for severe steering wheel and front wheel vibrations. The manufacturer was not informed of the failure. The failure mileage was approximately 265,000.
The contact owns a 2006 Ford F-350. The contact stated that while driving 35 MPH, the front of the vehicle started to wobble. While driving over a pothole, the vehicle wobbled violently. The contact was unable to control the vehicle while driving over 35 MPH. While driving at an undisclosed speed, the contact detected smoke coming from the vehicle. The engine warning light was illuminated. The contact called the local dealer, who informed him there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 99,856.
Engine & cooling all 33 →
The contact owns a 2006 Ford F-350. The contact stated that while driving 35 MPH, the front of the vehicle started to wobble. While driving over a pothole, the vehicle wobbled violently. The contact was unable to control the vehicle while driving over 35 MPH. While driving at an undisclosed speed, the contact detected smoke coming from the vehicle. The engine warning light was illuminated. The contact called the local dealer, who informed him there were no recalls. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 99,856.
2006F-350 super duty 5.4engine,,had to be replaced two and a half years ago the Ford dealer at cirroca of York,,told me that the new motor was improved that the new motors valve train was improved,,why wasn't it a recall,, if it would affect emissions and overall performance and reliability
Frequently asked questions
Is the 2006 Ford F-350 a good car?
Based on 145 owner complaints filed with NHTSA, the 2006 F-350 rates average: 1.2× as many complaints as a typical year of the F-350 at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2006 Ford F-350?
The steering — 51 complaints, 35% of all complaints for this model year, most often about linkages › arm › idler and attachment. Next are the suspension (50) and engine & cooling (33).
How many recalls does the 2006 Ford F-350 have?
There is 1 recall for the 2006 Ford F-350, the most recent from July 13, 2011 (brake lights). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford F-350?
The best years by complaints, compared at the same age, are 2009, 2007 and 2013. Years to avoid or approach with caution: 1999, 2000 and 1997. See the full Ford F-350 years comparison.
At what mileage do 2006 Ford F-350 problems happen?
The median mileage reported in complaints is about 60,000 miles; 39% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.