Most common 2022 Ford F-150 Lightning problems
Share of the 92 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Ford F-150 Lightning complaints by model year
Best F-150 Lightning years: 2025, 2024. Compare all years →
2022 Ford F-150 Lightning recalls (9)
Power train › Automatic transmission › Internal › Park pawl
Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park.
Remedy: The park module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed February 3, 2026. Owners may contact Ford customer service at 1-866-436-7332.
Exterior lighting
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning BEV vehicles previously repaired under recall number 23V418. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Remedy: Dealers will inspect and replace the rear lightbar and fasteners as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332.
Tires › Pressure monitoring and regulating systems
Ford Motor Company (Ford) is recalling certain 2022 F-150 Lightning BEV vehicles equipped with 20" or 22" all season tires that were repaired incorrectly under recall 22V-453. The tire pressure monitoring system (TPMS) light may not illuminate as intended, failing to warn the driver of low tire pressure.
Remedy: Dealers will update the body control module (BCM) software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332.
Electronic stability control (ESC)
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles previously repaired incorrectly under recall number 23V801. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle.
Remedy: Dealers will update the Accessory Protocol Interface Module (APIM) software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332.
Electrical system › Propulsion system › Traction battery
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 21, 2025.
Electrical system › Propulsion system › Traction battery
Ford Motor Company (Ford) is recalling certain 2022-2024 F-150 Lightning battery electric vehicles. A manufacturing defect in the high voltage battery cells may result in an internal short circuit.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will inspect and replace the high voltage battery array as necessary, free of charge.
Show 3 more recalls
Electronic stability control (ESC)
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle.
Remedy: The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023.
Exterior lighting
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 BEV vehicles. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Remedy: Dealers will replace the rear lightbar, free of charge. Owner notification letters were mailed October 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S30.
Tires › Pressure monitoring and regulating systems
Ford Motor Company (Ford) is recalling certain 2022 F-150 BEV vehicles equipped with 20" or 22" all season tires. The tire pressure monitoring system (TPMS) light may not illuminate as intended, failing to warn the driver of low tire pressure.
Remedy: The body control module (BCM) software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 20, 2022.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2022 Ford F-150 Lightning:
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
What 2022 Ford F-150 Lightning owners say
Electrical system all 35 →
The contact owns a 2022 Ford F-150. The contact stated that while driving at 20-25 MPH with the BlueCruise hands-free driving mode activated, the steering wheel inadvertently veered to the right, and the vehicle violently jerked across three lanes of traffic before slamming into the guardrail. No warning light was illuminated. The air bags did not deploy. There were no injuries sustained, and medical attention was not received. A police report was filed. The contact received a citation for reckless driving. The vehicle was towed to the dealer but had not yet been repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 25,000.
The contact owns a 2022 Ford F-150. The contact stated while driving 10 MPH, the messages "High Voltage Power Train Fault" and "Stop Driving and Contact Your Nearest Dealer" were displayed. The contact stated that he continued driving until it was safe to pull to the side of the road. The vehicle was towed to the residence. The vehicle was then towed to dealer, where it was diagnosed and determined that the battery module #4 had failed and needed to be replaced under Ford Campaign Number: 23H01. The vehicle was being repaired. The manufacturer was notified of the failure. The failure mileage was approximately 10,800.
Lights all 34 →
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the rear light bar was flickering intermittently. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure persisted. The contact stated that the failure had occurred increasingly, and the vehicle was taken back to the dealer, where it was diagnosed that microscopic cracks in the light bar had caused water intrusion, causing the rear light bar to fail. The dealer determined that the rear light bar needed to be replaced. The dealer informed the contact that the light bar needed to be replaced prior to performing an unknown recall repair. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 23S30. …
The contact owns a 2022 Ford F-150. The contact stated while the vehicle was parked, the rear light bar failed to function as intended. The contact stated the lights were inoperable and there was water inside the rear light bar. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The contact stated the rear light bar was replaced under recall. In addition, the contact stated that the rear light bar had failed three times since 2022. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair was not covered under warranty. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 1,000.
Transmission & drivetrain
I have received "High Voltage Battery Warnings" on 3 separate occasions (5/5/24, 5/9/24, 7/14/24), each time being told to stop the vehicle as soon as possible. On each occasion, once the vehicle is stopped it is bricked and cannot be driven at all. Fortunately, each of the three times I was able to stop the vehicle in a safe place. However, if others are experiencing the same issue, they may not be able to stop in a safe place. Furthermore, Ford has failed twice to fix the High Voltage battery issue, and the vehicle is currently at the dealer trying to resolve the issue for a third time. The fact that Ford does not know how to resolve this repeating issue is a large safety concern for two main reasons. …
Driving into the office today I was stopped at a stoplight. When it turned green I started to accelerate when a error came up on the screen saying the vehicle needed to be serviced immediately and the vehicle reduced power (<15 mph) in the middle of a busy road with a speed limit of 55 mph. In the FordPass App I got a message saying "Powertrain Malfunction/Reduced Power" What component or system failed or malfunctioned, and is it available for inspection upon request? Powertrain How was your safety or the safety of others put at risk? Yes, I was unable to go faster then 15 mph in a 55 mph zone while trying to move the vehicle to the side of the road. Has the problem been reproduced or confirmed by a dealer or independent service center? There are over 600 incidents reported of this problem by other F150 Lightning Owners in [redacted] that are compiled in the attached spreadsheet. …
2022 Ford F-150 Lightning engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined | Range |
|---|---|---|---|---|
| Electric | Single-speed | AWD | 78 / 63 / 70 MPGe | 320 mi |
EPA ratings. Class: Full-size pickup.
Frequently asked questions
Is the 2022 Ford F-150 Lightning a good car?
There isn't enough complaint history for the F-150 Lightning to compare model years reliably. So far owners have filed 92 complaints with NHTSA.
What is the most common problem with the 2022 Ford F-150 Lightning?
The electrical system — 35 complaints, 38% of all complaints for this model year, most often about 12v/24v/48v battery. Next are the lights (34) and transmission & drivetrain (13).
How many recalls does the 2022 Ford F-150 Lightning have?
There are 9 recalls for the 2022 Ford F-150 Lightning, the most recent from December 12, 2025 (park pawl). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Ford F-150 Lightning?
The best years by complaints, compared at the same age, are 2025 and 2024. See the full Ford F-150 Lightning years comparison.
At what mileage do 2022 Ford F-150 Lightning problems happen?
The median mileage reported in complaints is about 13,000 miles; 100% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.