Most common 2002 Chrysler PT Cruiser problems
Share of the 511 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chrysler PT Cruiser complaints by model year
Best PT Cruiser years: 2010, 2009, 2008. Years to avoid: 2001, 2002, 2006. Compare all years →
2002 Chrysler PT Cruiser recalls (3)
Steering › Hydraulic power assist › Hose, piping, and connections
On certain passenger vehicles equipped with 2.4l non-turbocharged engines and automatic transaxles, the power steering pressure hose May contact the automatic transaxle differential cover, potentially damaging the hose.
Remedy: Dealers will inspect and relocate, or replace as necessary, the power steering hose and confirm torque of the hose fastener at the steering gear end. The recall began on September 20, 2004.
Fuel system, gasoline › Delivery
On certain passenger vehicles, the fuel pump module mounting flange could leak fuel if the vehicle is involved in a rollover crash.
Remedy: Dealers will install a secondary seal over the fuel pump module. Owner notification began August 12, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the…
Electrical system › Wiring › Interior/under dash
Vehicle description: certain sport utility vehicles are being recalled for a software error in the instrument cluster microprocessor. Under certain conditions, the cluster, with the majority of its gauges, illumination, and warning lamps, could become inoperative.
Remedy: Dealers will re-flash the cluster software to correct the condition. Owner notification began October 8, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the…
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2002 Chrysler PT Cruiser:
Engine compartment fires
Pe04-028 was opened to investigate seven complaints alleging that the engine compartment caught fire on my 2002 pt cruiser vehicles.on June 3, 2004, daimlerchrysler (dcc) notified NHTSA of a safety defect in my 2001-2005 pt cruiser vehicles equipped with naturally aspirated 2.4l engines and automatic transaxles (recall 04v-268).the notification identified variation of the high pressure power steering hose routing,…
Safety belt cinching latch plate
There are no injuries or fatalities associated with this alleged defect.while conducting this investigation, odi found that the subject cinches meet the load bearing requirements of federal motor vehicle safety standard 208, and that many of the reported failures were due to incorrect child safety seat installations.
What 2002 Chrysler PT Cruiser owners say
Electrical system all 97 →
OK maybe 4th time is a charm on trying to get PT Cruiser off road. I had a fire in this vehicle due to overheating which was reported but dumb me put it out and replaced grill and radiator and had to take seperate loan out for $2500 in repairs and now vehicle won't start and now being told is computer well that explains why when we were trying to get out of car when was on fire the door locks didn't won't to work first time. The car is a 2002 with 100,000 miles on it and I have already put new tires on it and battery and had all these repairs done trying to save the car because I am a single mom on disability maybe since Chrysler is under investigation for injuries and deaths not being reported you can add me because I was burned during the fire trying to put out. …
Hello. I tried copying and pasting my letter into this box however, my letter is too long. Therefore, I am completing this online form and then will mail in my entire letter, documentation and the like to your mailing address along with a copy of this online form. The complaint is regarding my 2002 Chrysler PT Cruiser, VIN# [redacted] and it is relating to the fact Chrysler refuses to repair my vehicle under the current and active NHTSA recall # 01V288000 (instrument cluster problem). Today, 8/5/05 I will mail my letter detailing the entire problem but I am submitting this portion online to get the process started. Thank you for your time and attention. Sincerely, [redacted] . The vehicle was in motion when a pop noise was heard caused by a spark within the dash above the speedometer. White smoke had come billowing out of the instrument cluster. …
Body & structure all 67 →
The contact owns a 2002 Chrysler PT Cruiser. The contact stated that the rear quarter glass fasteners on both sides of the vehicle had started to separate from the vehicle. The contact stated that the windows were violently shaking while driving at various speeds. The contact was concerned that the windows might fall out while driving and cause injury to a pedestrian. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.
Tl* the contact owns a 2002 Chrysler PT Cruiser. The contact stated that while driving at approximately 5 MPH and making a right turn, the vehicle came to an abrupt stop. The contact exit the vehicle and discovered that the front passenger side sub frame had excessive rust and fractured. The vehicle was towed to an independent mechanic and was diagnosed that the front passenger frame, the cv axles and the lower control arms with ball joint and the stabilizer link had fractured. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 84,000.
Engine & cooling all 60 →
While driving the vehicle I could begin to smell a strong odor of gas them almost like the smell of plastic melting and the vehicle engine started running hot temperature so I immediately turned off the engine as I pulled over to the side of the road and as I stepped out of the car aflame began under the hood and ended up burning my entire engine. Fire department had to come and extinguish the car.
OK maybe 4th time is a charm on trying to get PT Cruiser off road. I had a fire in this vehicle due to overheating which was reported but dumb me put it out and replaced grill and radiator and had to take seperate loan out for $2500 in repairs and now vehicle won't start and now being told is computer well that explains why when we were trying to get out of car when was on fire the door locks didn't won't to work first time. The car is a 2002 with 100,000 miles on it and I have already put new tires on it and battery and had all these repairs done trying to save the car because I am a single mom on disability maybe since Chrysler is under investigation for injuries and deaths not being reported you can add me because I was burned during the fire trying to put out. …
2002 Chrysler PT Cruiser engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.4L 4-cyl | 5-speed manual | FWD | 19 / 27 / 22 |
| 2.4L 4-cyl | 4-speed automatic | FWD | 17 / 23 / 20 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2002 Chrysler PT Cruiser a good car?
Based on 511 owner complaints filed with NHTSA, the 2002 PT Cruiser rates avoid: 2.4× as many complaints as a typical year of the PT Cruiser at the same age. It is one of the PT Cruiser years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2002 Chrysler PT Cruiser?
The electrical system — 97 complaints, 19% of all complaints for this model year, most often about wiring › interior/under dash. Next are the body & structure (67) and engine & cooling (60).
How many recalls does the 2002 Chrysler PT Cruiser have?
There are 3 recalls for the 2002 Chrysler PT Cruiser, the most recent from June 3, 2004 (hose, piping, and connections). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chrysler PT Cruiser?
The best years by complaints, compared at the same age, are 2010, 2009 and 2008. Years to avoid or approach with caution: 2001, 2002 and 2006. See the full Chrysler PT Cruiser years comparison.
At what mileage do 2002 Chrysler PT Cruiser problems happen?
The median mileage reported in complaints is about 51,000 miles; 47% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.