Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2004 Chrysler Crossfire owners, lightly cleaned up (personal details are redacted by NHTSA).
While cruising at 55 miles per hour, an unexpected occurrence took place - the engine abruptly ceased to function. I found myself on a two-lane highway in the midst of a construction zone, where the highway was reduced to a single lane, flanked by barriers. In a situation devoid of power assistance, I navigated the immobile vehicle between these barriers to reach a secure location, narrowly evading a potential accident.This issue is perilous and disturbingly common among these vehicles, yet it lacks a definitive diagnosis or solution. Even the computer scans fail to pinpoint the root cause behind this disruptive problem. I had no choice but to have the vehicle towed, and an automotive technician subsequently replaced the crank position sensor, just one of the many potential culprits in this recurring issue. …
I was driving down the interstate and engine suddenly cut off and I had to push it to the side of the road, I could have been rear-ended easily. There was no power and engine would not turn over, only electronics would light up and engine fan would run at a high rate of speed.I do not understand why Chrysler/Mercedes would not have a recall on this yet. Apparently it is the rcm module that has bad solder points so I have heard. Very dangerous that this is happening to a vehicle with under 100K miles. It has happened before and left me stranded a couple times, and this time it would not start at all so I had to get a tow truck to tow it 27 miles home. If this happened to a new driver or elderly person this could have been very dangerous. I can't even imagine what would have happened if this happened while I was on a road trip or driving through atlanta or something.
Tl* the contact owns a 2004 Chrysler Crossfire. The contact stated that the ignition locked, which prevented the vehicle from being driven for an extended period of time. Kernersville Chrysler Dodge Jeep Ram (950 nc-66, kernersville, nc 27284, [phone]) diagnosed that the electrical wires caused the failure. The vehicle was repaired momentarily, but the failure recurred. The dealer was contacted again and stated that the ignition switch needed to be replaced. A second dealer (ilderton Dodge Chrysler Jeep Ram, 701 s main st, high point, nc 27260, [phone]) also diagnosed that the ignition switch needed to be replaced. The manufacturer had not issued a recall for the failure and suggested taking the vehicle to the dealer for repairs. The vehicle was not repaired. The approximate failure mileage was 30,000.
My car was on the highway and it shut down. No warning. No check engine light on prior to the car shutting down while driving 60 MPH. When I attempted to turn it on all of the loaner lights would turn on. Including the air, radio,windows etc. I tried to get a jump and nothing happened. Called for a tow truck and as soon as it showed up it cranked up. This has happened again after turning off my car and trying to start it again but nothing happens. I've heard of this happening with crossfires and it's unbelievable that there has not been a recall. Also there has been no recall regarding the ignition. Problems with turning the key if removed. The key has to remain in the ignition. I've had a friend who's Crossfire does that also as well as mine.
Tl* the contact owns a 2004 Chrysler Crossfire. While attempting to start the vehicle, the ignition failed to start and an unusual warning indicator illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the ignition failed and needed to be replaced. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was notified of the failure and did not assist. The failure mileage was approximately 101,000.
This is my 2nd request. I have defective airbags & they have been this way since the car was new. It only has 40K miles on it. I have tried contacting Chrysler numerous times, they have not replied. This is very dangerous. I have gone to numerous dealerships, private repairs and put over $2500 of my own money into this issue, but it still isn't working etc. Everyone says this call should be recalled. I need help!
Tl* the contact owns a 2004 Chrysler Crossfire. The contact stated that the vehicle failed to start when the key was turned in the ignition. There were no warning indicators illuminated. The vehicle was taken to chapman Chrysler (3175 e sarah avenue, las vegas, nv), but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 43,802. The VIN was unknown.
Tl* the contact owns a 2004 Chrysler Crossfire. While driving various speeds, the vehicle stalled and also failed to start on several occasions. The failures recurred intermittently. The vehicle was taken to an independent mechanic, but the cause of the failure was unable to be determined. The manufacturer was notified of the failure. The failure mileage was 79,000.
Tl* the contact owns a 2004 Chrysler Crossfire. The contact stated that the ignition switch failed to turn. The failure recurred numerous times. The vehicle was taken to a dealer where it was diagnosed that the ignition switch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 118,000.
Tl* the contact owns a 2004 Chrysler Crossfire. The contact stated that the ignition key malfunctioned and the vehicle could not be started. The failure was not diagnosed or repaired. The local dealer and manufacturer were not notified of the failure. The VIN was not available. The failure mileage was 60,000.
Electrical complaints in other Crossfire years
Frequently asked questions
How common are electrical problems on the 2004 Chrysler Crossfire?
NHTSA has 50 complaints about the electrical system of the 2004 Chrysler Crossfire, 46% of the model year's 109 complaints. The component named most often is ignition (4 mentions).
Is there a recall for 2004 Chrysler Crossfire electrical problems?
No. NHTSA lists no electrical system recall for the 2004 Chrysler Crossfire. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2004 Chrysler Crossfire electrical problems start?
Half of the complaints with a recorded mileage happened before about 65,000 miles, and 12% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 1 fire and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.