2016 Chevrolet Volt Electrical Problems

Which parts fail

• Propulsion system › Traction battery
  1
• Propulsion system
  1
• Propulsion system › Fuses, relays, contacts, and shunts
  1
• Propulsion system › Traction battery › Management system/energy control module (BMS/becm)
  1

Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).

Mileage when the problem started

• Under 25k
  726%
• 25k–50k
  830%
• 50k–75k
  27%
• 75k–100k
  622%
• 100k–150k
  27%
• 150k+
  27%

Owner reports

Selected complaints filed with NHTSA by 2016 Chevrolet Volt owners, lightly cleaned up (personal details are redacted by NHTSA).

The contact owns a 2016 Chevrolet Volt. The contact stated that while the daughter was driving in reverse the warning message "Reduced Propulsion" had displayed and suddenly the power steering failed and the vehicle lurched backward and crashed into a utility pole. During the incident, the driver pressed the brake pedal but the vehicle did not stop. No injuries were reported and no police report was taken. The daughter was able to drive the vehicle home in "Limp" Mode. The contact later examined the vehicle and diagnosed that the engine battery ECM had failed. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the manufacturer's extended coverage for the failure. The failure mileage was 89,800.

The car has experienced a 'BECM' failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued 'special coverage N232432680'. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn't covered based on my vin but they didn't know why our vin was left out of the coverage. Obviously if they thought our car didn't have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. …

The contact owns a 2016 Chevrolet Volt. The contact stated that while starting and driving at an undisclosed speed, the "Reduced Propulsion" message was displayed. Additionally, after parking the vehicle, the "Shift To Park" message was displayed, and the vehicle failed to turn off. The contact pressed the Start/Stop button and then opened and closed the front driver's side door to turn off the vehicle. The vehicle later failed to charge and start as needed. The vehicle was towed to the dealer, where it was determined that the Battery Energy Control Module (BECM) needed to be replaced; however, the part was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 83,574. The VIN was unavailable.

The contact owns a 2016 Chevrolet Volt. The contact stated that after starting the vehicle, the vehicle initially failed to shift into drive. After the vehicle was shifted into drive, the contact stated that while driving at an undisclosed speed, the vehicle lost significant motive power with the "Low Propulsion Power" message displayed. The contact pulled over to the shoulder of the roadway, where the vehicle stalled and failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the battery energy control module. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 160,000.

The contact owns a 2016 Chevrolet Volt. The contact stated while driving 40 MPH, the battery was fully charged; however, the mileage range went to 0. The contact stated that the fuel system engaged, and he drove to the dealer, where it was diagnosed that the electronic control module (ECM) had failed and needed to be replaced. The contact related the failure to GM Campaign Number: N232432680; however, the dealer informed the contact that the vehicle was not covered. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because the vehicle had a Salvage Title. The failure mileage was approximately 44,000.

The contact owns a 2016 Chevrolet Volt. The contact stated that while operating vehicle the "Propulsion Error" was displayed, and the message "Shift to Park" was displayed while driving. Additionally, the vehicle occasionally failed to immediately start. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the Battery Energy Control Module (BECM) was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in the Manufacturer's Extended Warranty Coverage related to the failure. The failure mileage was 98,500.

The contact owns a 2016 Chevrolet Volt. The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle stalled. The accelerator pedal was released, and the vehicle returned to normal operation. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Action Number: PE23022 (Electrical System) and Special Coverage: N232432680 (Battery Energy Control Module Malfunction); however, the vehicle was not covered under the Special Coverage. The manufacturer was made aware of the failure. The failure mileage was approximately 71,000.

The contact owns a 2016 Chevrolet Volt. The contact stated while driving at an undisclosed speed, the "Engine Propulsion Reduced" message was displayed, and the vehicle was driven to an Auto Parts store. The contact called the local dealer and was advised to replace the propulsion fuse in the vehicle. The contact purchased a replacement fuse and replaced the faulty fuse. The vehicle was driven to the dealer two days later to be diagnosed. The vehicle was diagnosed, and the contact was informed that the EGR valve had malfunctioned and needed to be replaced. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

The contact owns a 2016 Chevrolet Volt. The contact stated that while at a stop light, the vehicle suddenly shut off and would not restart. The vehicle was towed to the local dealer who diagnosed that the high voltage battery was faulty and needed to be replaced. An engineer was sent by the manufacturer to examine the vehicle and confirmed that the high voltage battery was faulty. The contact was later informed that the manufacturer had authorized the high voltage battery replacement. The failure mileage was 91,000. The VIN was not available.

The contact owns a 2016 Chevrolet Volt. The contact stated that while the vehicle was parked, the check engine warning light illuminated. The contact used a scanner and retrieved DTC: U2603-U2606 and U2607-U2622. The dealer was made aware of the failure. The vehicle was scheduled for an upcoming diagnostic test. The vehicle was not yet diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 95,000.

NHTSA investigations

Electrical complaints in other Volt years