Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2007 Chevrolet Silverado 1500 owners, lightly cleaned up (personal details are redacted by NHTSA).
The dash of my Chevy Silverado is cracked and continues to crack, on 9.27.2023 a couple of large pieces broke completely out of the dash which is right by the airbag on the right side of the dash. Now I have a gaping hole. As far as I see at this time there are no recalls for the dash.
Frame beaming on the 2007 x tra cab classic truck. General motors campaign #pit3009j. The problem is so bad that it shakes the seat so violently that it is a health hazard to drive around. I have been driving my truck for two years now as my daily driver. The frame shakes so bad on the freeway that it has caused me back strains and neck pain when driving for over an hour. I have been to americas tire many times thinking it was a tire problem they have rebalanced the tires and even replaced the whole set with another brand with no improvement. After my recent mri from back pain I believe that driving this truck is fully to blame for my pain. …
Multiple cracks in the dashboard in and around the passenger airbag and drivers side. Pieces become a hazard in the event of a collision as they could become projectiles. Dash cracks lead to loss of structural integrity of the dash system which May also impede the ability of the airbag to function. This problem has been well documented and reported by multitudes of consumers throughout the nation. GM/Chevrolet refuse to acknowledge that there is a manufacturing problem and refused to provide any support when contacted via phone. The loss of structural integrity also poses a hazard as the pieces vibrate and cause a distraction for the driver. My dash board was replaced at approx. 80000 miles due to the same issue in nearly the same location. This problem should warrant a recall and/or a streamlined avenue to repair the known defect. …
Tl* the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that on both the driver side and passenger side sections of the dash board had experienced multiple cracks that extended approximately 18 inches each. The contact indicated that the dash board was made of a hard plastic material. The vehicle was taken to the local dealer gent Chevrolet located at (2715 35th ave, greeley co) who indicated that the dashboard needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 78,000.
Tl* the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that the vehicle did not pass inspection because the frame was rusted. The vehicle was deemed unsafe to drive. The vehicle was taken to an independent mechanic where the frame was patched with adhesive. The vehicle was taken back to get inspected and the contact was informed that the remedy was insufficient. The vehicle was not taken to a dealer for diagnostic testing or repairs. The manufacturer was not made aware of the failure. The failure mileage was 108,331.
Tl* the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that while driving at speeds above 30 MPH, the front end of the vehicle would experience severe shaking and vibrating. The contact discovered that the passenger side mounting bracket for the suspension and steering had separated from the vehicle and a sub frame had fractured near the bracket. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.
The forward dash has contyto crack and break apartvat several areas including the passenger side airbag location. This is a know problem with GM and they only offer "goodwill" assistance for customers just outside the bumper to bumper warranty. Repairs cost over 1000.00 for this issue that can sometimes have to be done multiple times. Looking to finally getting this addressed and not swept under the rug.
Tl* the contact owns a 2007 Chevrolet Silverado 1500. The contact noticed that the dashboard was cracking. The contact was concerned of air bag deployment due to the crack. A dealer was not contacted. The vehicle was not repaired. The manufacturer was not notified of the failure. The VIN was included in NHTSA campaign number: 16V383000 (air bags). The approximate failure mileage was 105,000.
Tl* the contact owns a 2007 Chevrolet Silverado 1500. The contact stated that dashboard fractured on both the driver and passenger side. The contact mentioned that the fracture on the passenger side extended to the air bag. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 111,000.
The dash board is cracked in multiple spots and has started to crack and fall into the mechanical components underneath. Has 6 or more cracks approximately 6-12 inches. It started with one crack and has continue to have more, happens while parked and driving.
Body complaints in other Silverado 1500 years
Frequently asked questions
How common are body problems on the 2007 Chevrolet Silverado 1500?
NHTSA has 55 complaints about the body & structure of the 2007 Chevrolet Silverado 1500, 6% of the model year's 849 complaints. The component named most often is body (33 mentions).
Is there a recall for 2007 Chevrolet Silverado 1500 body problems?
No. NHTSA lists no body & structure recall for the 2007 Chevrolet Silverado 1500, though it has 2 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2007 Chevrolet Silverado 1500 body problems start?
Half of the complaints with a recorded mileage happened before about 78,000 miles, and 22% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 0 fires and 4 injuries and 1 death to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.