What gets recalled
2004 Chevrolet S10 recalls (1)
Equipment › Other › Labels
Certain pickup trucks and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection."
Remedy: Owners will be provided with correct labels and installation instructions. Owner notification began on June 4, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.
2003 Chevrolet S10 recalls (1)
Equipment › Other › Labels
Certain pickup trucks and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection."
Remedy: Owners will be provided with correct labels and installation instructions. Owner notification began on June 4, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.
2001 Chevrolet S10 recalls (1)
Seat belts
Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and Mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no.
Remedy: Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
2000 Chevrolet S10 recalls (4)
Equipment › Other › Labels
Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles were built with incorrect payload information on the vehicle certification label. The payload shown on the label is greater than the maximum validated payload.
Remedy: Owners will be sent a new label for installation on the driver's door of the vehicle.
Seat belts
Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and Mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no.
Remedy: Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Vehicle description: light duty pickup trucks equipped with 4-wheel disc brakes. Some of these vehicles have an antilock brake system (ABS) motor containing an out-of-specification spring clip. This clip could allow the motor bearing to become misaligned. If misalignment occurs, eventually the ABS would be non-functional.
Remedy: Dealers will replace the brake pressure module valve assembly.
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Vehicle description: s -trucks equipped with 2 wheel drive. These vehicles May have had the right-hand antilock brake system (ABS) module feed pipe and/or brake crossover pipe tube nuts tightened without seating the pipe-flared-ends enough to withstand normal assembly and vehicle inputs without partially unseating.
Remedy: Dealers will inspect the brake pipe union for signs of brake fluid, and if necessary, install a new brake pipe union.
1998 Chevrolet S10 recalls (6)
Electrical system › 12V/24V/48V battery
Vehicle description: electric passenger vehicles and pickup trucks containing a nickel metal hydride (nimh) battery pack. These vehicles contain software within the battery pack module intended to disable the vehicle from being driven if the electrical resistance with the battery pack exceeds a prescribed value.
Remedy: Dealers will install revised software in the battery pack module.
Exterior lighting
Vehicle description: light duty pickup trucks and sport utility vehicles. These vehicles fail to comply with the requirements of FMVSS no. 108, "lamps, reflective devices, and associated equipment." the daytime running lights built with a candela value greater than 3,000 cannot be mounted higher than 864mm above the road…
Remedy: Dealers will install a revised wiring harness that changes the drl's from high beam to low beam drl's, and install new long-life low beam bulbs.
Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
Vehicle description: electric pickup trucks. A condition in which the fuel-fired heater fill pipe ground strap contacts the rear passenger side brake pipe.
Remedy: Dealers will relocate the ground strap attachment, inspect the brake pipe for wear, and replace the brake pipe if necessary.
Visibility › Defroster/defogger/HVAC system
Vehicle description: light duty pickup trucks equipped with electric drive. Rapid fogging of the interior glass can occur within two minutes after the heat is turned on if (1) the outside temperature is between 35 and 76 degrees fahrenheit and (2) water has collected on the heat exchanger during previous operation of the air…
Remedy: Owners are being provided with a caution label and supplemental insert for their owner's manual advising them to follow a "stop and wait" procedure to help avoid window fogging while driving.
Show 2 more recalls
Electrical system › Wiring › Front underhood
Vehicle description: light duty pickup trucks and multi-purpose vehicles. An engine electrical wiring-harness clip can melt and drip onto the exhaust manifold.
Remedy: Dealers are contacting owners by telephone to have their vehicles towed to the dealer and alternate transportation provided to them until the dealer can reroute the electrical wiring-harness.
Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. A fatigue fracture of the rear axle right-hand brake pipe can occur causing a slow brake fluid leak resulting in a soft brake pedal.
Remedy: Dealers will inspect and replace the brake pipe.
1997 Chevrolet S10 recalls (6)
Visibility › Windshield wiper/washer
On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor May fail due to cracked solder joints on the controller circuit board. The windshield wipers could work intermittently or not at all.
Remedy: Dealers will replace the wiper motor circuit board and cover. Owner notification began on June 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free…
Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
Vehicle description: electric pickup trucks. A condition in which the fuel-fired heater fill pipe ground strap contacts the rear passenger side brake pipe.
Remedy: Dealers will relocate the ground strap attachment, inspect the brake pipe for wear, and replace the brake pipe if necessary.
Electrical system › 12V/24V/48V battery
Vehicle description: generation 1 electric light duty pickup trucks. These vehicles were built with a charge port assembly that could fail during a charging event.
Remedy: Dealers will replace the charge port assembly with a redesigned charge port assembly.
Visibility › Defroster/defogger/HVAC system
Vehicle description: light duty pickup trucks equipped with electric drive. Rapid fogging of the interior glass can occur within two minutes after the heat is turned on if (1) the outside temperature is between 35 and 76 degrees fahrenheit and (2) water has collected on the heat exchanger during previous operation of the air…
Remedy: Owners are being provided with a caution label and supplemental insert for their owner's manual advising them to follow a "stop and wait" procedure to help avoid window fogging while driving.
Show 2 more recalls
Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
Vehicle description: light duty passenger pickup trucks equipped with 4.3l engines. The front brake line can contact the left-hand side of the engine oil pan causing the brake line to wear to the point of brake fluid loss during brake application.
Remedy: Dealers will inspect the clearance between the oil pan and the brake line. If the clearance is 6mm or less, dealers will install an additional brake line clip and if there was contact between the oil pan and brake line,…
Seat belts
Vehicle description: extended cab pickup trucks equipped with 60/40 front bench seats and extended cab pickup trucks and 2-door utility vehicles equipped with manual locking recliner bucket seats. The outboard safety belt webbing on the driver's and/or passenger's seat can separate during a frontal impact.
Remedy: Dealers will install a protective cover over the recliner mechanism.
1996 Chevrolet S10 recalls (7)
Visibility › Windshield wiper/washer
On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor May fail due to cracked solder joints on the controller circuit board. The windshield wipers could work intermittently or not at all.
Remedy: Dealers will replace the wiper motor circuit board and cover. Owner notification began on June 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free…
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Vehicle description: certain 4-wheel drive pickup trucks and sport utility vehicles equipped with ABS (antilock braking system) manufactured from September 1989 through August 1996. Under certain driving conditions the switch which signals the ABS system whether the vehicle is in 2-wheel or 4-wheel drive can malfunction causing…
Remedy: Dealers will replace or repair the 4-wheel/2-wheel drive switch.
Visibility › Windshield wiper/washer
Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
Remedy: Dealers will replace the wiper motor circuit board and cover.
Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
Vehicle description: light duty passenger pickup trucks equipped with 4.3l engines. The front brake line can contact the left-hand side of the engine oil pan causing the brake line to wear to the point of brake fluid loss during brake application.
Remedy: Dealers will inspect the clearance between the oil pan and the brake line. If the clearance is 6mm or less, dealers will install an additional brake line clip and if there was contact between the oil pan and brake line,…
Show 3 more recalls
Seat belts
Vehicle description: extended cab pickup trucks equipped with 60/40 front bench seats and extended cab pickup trucks and 2-door utility vehicles equipped with manual locking recliner bucket seats. The outboard safety belt webbing on the driver's and/or passenger's seat can separate during a frontal impact.
Remedy: Dealers will install a protective cover over the recliner mechanism.
Visibility › Windshield
The top coat paint severely peels due to overbaking of the powder primer prior to the top coat application. Since the windshield primer and adhesive adhere to the top coat paint onthe windshield opening flange, the windshield does not comply with federal motor vehicle safety standard no. 212, "windshield mounting."
Remedy: All vehicles have been repurchased. This campaign is 100%.
Power train › Manual transmission
Some of these trucks were built with transmissions containing parts which were not machined to GM's specifications.
Remedy: Dealers will inspect the transmission main shaft output torque using a special tool. If the output torque does not meet specifications, the transmission will be replaced.
1995 Chevrolet S10 recalls (5)
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Vehicle description: certain 4-wheel drive pickup trucks and sport utility vehicles equipped with ABS (antilock braking system) manufactured from September 1989 through August 1996. Under certain driving conditions the switch which signals the ABS system whether the vehicle is in 2-wheel or 4-wheel drive can malfunction causing…
Remedy: Dealers will replace or repair the 4-wheel/2-wheel drive switch.
Visibility › Windshield wiper/washer
Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
Remedy: Dealers will replace the wiper motor circuit board and cover.
Seat belts
Vehicle description: extended cab pickup trucks equipped with 60/40 front bench seats and extended cab pickup trucks and 2-door utility vehicles equipped with manual locking recliner bucket seats. The outboard safety belt webbing on the driver's and/or passenger's seat can separate during a frontal impact.
Remedy: Dealers will install a protective cover over the recliner mechanism.
Steering › Gear box › Shaft sector
The intermediate steering shaft loosens at the steering shaft to steering gear coupling. With this looseness, the yoke pinch bolt can wear on the splines of the shaft until there is no longer an interference between the splines and the bolt.
Remedy: Dealers will retorque the upper and lower bolts to correct specifications.
Show 1 more recall
Engine and engine cooling › Cooling system › Fan
Fan blade rivet breakage can occur causing the fan blade to separate from the spider.
Remedy: Dealers will inspect and replace, if necessary, the fan with a newer fan having thicker-headed rivets.
Frequently asked questions
How many recalls does the Chevrolet S10 have?
NHTSA lists 21 recalls for the Chevrolet S10 across 8 model years.
How do I know if my Chevrolet S10 has an open recall?
Enter your 17-character VIN in our VIN decoder & recall check or on nhtsa.gov/recalls. Dealers fix recalls for free, even if you are not the original owner.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.