Most common 2010 Chevrolet Cobalt problems
Share of the 583 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Cobalt complaints by model year
Best Cobalt years: 2010, 2009, 2008. Years to avoid: 2006, 2005, 2007. Compare all years →
2010 Chevrolet Cobalt recalls (5)
Air bags › Side/window
General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door.
Remedy: GM will notify owners, and dealers will inspect the sensor's wiring in the driver's door and make repairs as necessary, free of charge. The recall began on September 8, 2015.
Electrical system › Ignition
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the…
Steering › Electric power assist system
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014.
Air bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect.
Steering › Electric power assist system
General motors is recalling certain model year 2005-2010 Chevrolet cobalt and model year 2007-2010 Pontiac g5 vehicles equipped with electric power steering. The driver May experience a sudden loss of power steering assist that could occur at any time while driving.
Remedy: Dealers will replace the electric power steering motor free of charge. Owners are being notified on a rolling basis between March 29 through November 2010. A copy of the mailing schedule is located in the recall file.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2010 Chevrolet Cobalt:
Fuel Line Leak
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM).
What 2010 Chevrolet Cobalt owners say
Steering all 242 →
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 55 MPH, the power steering and brakes became inoperable. The driver was able to coast to the side of the road. The check engine warning light was illuminated after the failure. The vehicle was towed to her parent's residence. The vehicle was serviced by an independent mechanic, who stated that the failure was due to the ignition switch. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not covered under the recall. The contact stated that the failure was related to NHTSA Campaign Number: 14V171000 (Electrical System). The failure mileage was approximately 260,000.
The contact's daughter owns a 2010 Chevrolet Cobalt. The contact stated that while driving at various speeds, the power steering assist failed to operate as needed. There was no warning light illuminated. Due to the failure, extra effort was needed to steer the vehicle. The vehicle was not diagnosed or inspected for the failure. The manufacturer was notified of the failure and informed the contact that there were no recalls related to the failure for the VIN. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 14V153000 (Steering). The vehicle was not repaired. The failure mileage was approximately 54,000.
Electrical system all 128 →
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 55 MPH, the power steering and brakes became inoperable. The driver was able to coast to the side of the road. The check engine warning light was illuminated after the failure. The vehicle was towed to her parent's residence. The vehicle was serviced by an independent mechanic, who stated that the failure was due to the ignition switch. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not covered under the recall. The contact stated that the failure was related to NHTSA Campaign Number: 14V171000 (Electrical System). The failure mileage was approximately 260,000.
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving approximately 30 MPH the fuel indicator began to drop rapidly. The contact stated that he did not notice any warning lights. The contact drove the vehicle to his residence and smelled the odor of fuel and noticed a long streak of fuel, and a puddle of fuel underneath the driver's side door by the rear driver's side tire. The contact observed that the fuel line located under the driver's side of the vehicle had ruptured. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 120,000.
Fuel & propulsion system all 122 →
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving approximately 30 MPH the fuel indicator began to drop rapidly. The contact stated that he did not notice any warning lights. The contact drove the vehicle to his residence and smelled the odor of fuel and noticed a long streak of fuel, and a puddle of fuel underneath the driver's side door by the rear driver's side tire. The contact observed that the fuel line located under the driver's side of the vehicle had ruptured. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 120,000.
The contact owns a 2010 Chevrolet Cobalt. The contact stated that his son called and stated he detected an abnormal odor of fuel inside the vehicle. The driver looked around the vehicle and noticed liquid emerging near the driver's side rear tire. The driver stated that the vehicle was hard to start. The contact inspected the vehicle and noticed the fuel lines were rusted. There were no warning lights illuminated. The vehicle was taken to an independent mechanic where two sections of rusted fuel lines were replaced. The contact called the local dealer however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 85,933.
2010 Chevrolet Cobalt engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 2.2L 4-cyl | 5-speed manual | FWD | 25 / 37 / 30 |
| 2.2L 4-cyl | 4-speed automatic | FWD | 24 / 33 / 27 |
| 2.0L 4-cyl turbo | 5-speed manual | FWD | 22 / 30 / 25 |
EPA ratings. Class: Subcompact car.
Frequently asked questions
Is the 2010 Chevrolet Cobalt a good car?
Based on 583 owner complaints filed with NHTSA, the 2010 Cobalt rates better than average: 66% fewer complaints than a typical year of the Cobalt at the same age. It is one of the best Cobalt years by this measure. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2010 Chevrolet Cobalt?
The steering — 242 complaints, 42% of all complaints for this model year, most often about electric power assist system. Next are the electrical system (128) and fuel & propulsion system (122).
How many recalls does the 2010 Chevrolet Cobalt have?
There are 5 recalls for the 2010 Chevrolet Cobalt, the most recent from August 10, 2015 (side/window). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chevrolet Cobalt?
The best years by complaints, compared at the same age, are 2010, 2009 and 2008. Years to avoid or approach with caution: 2006, 2005 and 2007. See the full Chevrolet Cobalt years comparison.
At what mileage do 2010 Chevrolet Cobalt problems happen?
The median mileage reported in complaints is about 64,000 miles; 32% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.