Most common 2025 Chevrolet Blazer EV problems
Share of the 21 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Blazer EV complaints by model year
2025 Chevrolet Blazer EV recalls (3)
Parking brake
General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Blazer EV vehicles that may have been repaired incorrectly under recall 25V433. The rear parking brake wiring harness may become damaged or corroded, resulting in unintended activation of the parking brake or loss of the parking brake function.
Remedy: Dealers will replace the chassis harness, free of charge. Owner notification letters were mailed on February 25, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020.
Parking brake
General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Blazer EV vehicles. The rear parking brake wiring harness may become damaged or corroded, resulting in unintended activation of the parking brake or loss of the parking brake function.
Remedy: Dealers will inspect the harness and, if necessary, reroute the harness and install anti-abrasive tape. Any harness that has existing damage will be replaced. Repairs will be performed free of charge.
Latches/locks/linkages › Doors › Latch
General Motors, LLC (GM) is recalling certain 2025 Chevrolet Blazer, Blazer EV, and Equinox vehicles. The door strikers were not properly heat-treated, which can cause them to break.
Remedy: Dealers will replace all four side door strikers and attachment bolts, free of charge. All affected vehicles are still in dealership inventory and therefore no owner notification letters are expected to be mailed.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2025 Chevrolet Blazer EV:
Electronic Brake Module Component Failure
On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a "Brake System Failure" message at start up or while driving.
What 2025 Chevrolet Blazer EV owners say
Driver assistance
The contact owns a 2025 Chevrolet Blazer EV. The contact stated that while driving at various speeds, there was a clicking sound coming from the front suspension of the vehicle, and the vehicle was difficult to drive in a straight line or turn in either direction. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The contact was informed that the vehicle could not be repaired, and a buyback was offered for the vehicle. Additionally, while driving at an undisclosed speed, the Forward Collision Avoidance system erroneously activated, causing the vehicle to abruptly stop in the middle of the road. The vehicle was taken to the local dealer, who reprogrammed the Forward Collision Avoidance sensors, but the failure persisted. Additionally, the charging port had malfunctioned and became inoperable. …
The contact owns a 2025 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed, the Forward Collision Avoidance system activated while there were no objects or persons in front of the vehicle. The failure reoccurred on several occasions. The Forward Collision Avoidance warning light illuminated, and the message "Approaching Person" was displayed. The vehicle was towed to a dealer to be diagnosed; however, the failure was not duplicated. The vehicle was not diagnosed or repaired. The vehicle was taken back to the dealer to be diagnosed; however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 4,100.
Brakes
The contact owns a 2025 Chevrolet Blazer. The contact received notification of NHTSA Campaign Number: 25V433000 (Parking Brake); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and diagnosed that the windshield was not installed properly and needed to be replaced. The contact stated that while raining, water leaked into the vehicle through the windshield onto the dashboard. The contact stated that the seal had detached on the passenger's and driver's sides of the vehicle. The contact stated that while driving at an undisclosed speed, the vehicle shifted into park(P). The vehicle had to be turned off and restarted to shift out of park(P). The failure had occurred while driving, idling, and while parked. There were no warning lights illuminated. …
Multiple safety-critical malfunctions have occurred on this vehicle involving unintended braking, unintended acceleration, and false activation of driver-assist systems. These events did not happen at the same time and occurred under normal driving conditions. At various points, the vehicle has suddenly applied the brakes without driver input, including hard braking events that felt like an automatic emergency braking activation when no hazard was present. In separate incidents, the parking brake has engaged while the vehicle was in motion, causing abrupt deceleration. There have also been instances of unintended acceleration where the vehicle surged forward briefly without additional throttle input. These malfunctions appear to be related to electrical or ADAS system faults affecting braking logic and propulsion control. …
Electrical system
Multiple safety-critical malfunctions have occurred on this vehicle involving unintended braking, unintended acceleration, and false activation of driver-assist systems. These events did not happen at the same time and occurred under normal driving conditions. At various points, the vehicle has suddenly applied the brakes without driver input, including hard braking events that felt like an automatic emergency braking activation when no hazard was present. In separate incidents, the parking brake has engaged while the vehicle was in motion, causing abrupt deceleration. There have also been instances of unintended acceleration where the vehicle surged forward briefly without additional throttle input. These malfunctions appear to be related to electrical or ADAS system faults affecting braking logic and propulsion control. …
This is a report of defective software that could increase the chances of an accident, injury and or death. This vehicle features a built-in garage door remote which is utilized exclusively through the touch screen. However, when the vehicle is in reverse the backup cameras restrict access to the needed menu. After backing up and putting the car in drive there is a delay before the back up camera turns off. This creates a situation in which the driver must wait in the middle of the road after placing the car in drive before being able to close the garage door. In seeking solutions from online forums, some drivers have reported their Blazer EVs allow the button to be accessed while others report they do not, so I speculated perhaps I missed a software update, but per the car's OTA system, the vehicle's software is current as of the time of this submission. …
2025 Chevrolet Blazer EV engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined | Range |
|---|---|---|---|---|
| Electric | Single-speed | FWD | 114 / 95 / 104 MPGe | 312 mi |
| Electric | Single-speed | AWD | 102 / 87 / 95 MPGe | 283 mi |
| Electric | Single-speed | RWD | 106 / 85 / 95 MPGe | 334 mi |
EPA ratings. Class: Small SUV.
Frequently asked questions
Is the 2025 Chevrolet Blazer EV a good car?
There isn't enough complaint history for the Blazer EV to compare model years reliably. So far owners have filed 21 complaints with NHTSA.
What is the most common problem with the 2025 Chevrolet Blazer EV?
The driver assistance — 14 complaints, 67% of all complaints for this model year, most often about warnings. Next are the brakes (8) and electrical system (5).
How many recalls does the 2025 Chevrolet Blazer EV have?
There are 3 recalls for the 2025 Chevrolet Blazer EV, the most recent from January 22, 2026 (parking brake). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
At what mileage do 2025 Chevrolet Blazer EV problems happen?
The median mileage reported in complaints is about 4,000 miles; 100% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.