Chevrolet 6500XD complaints by model year
2019 Chevrolet 6500XD recalls (5)
Suspension › Rear › Springs › Leaf spring assembly › Hanger/bracket
Isuzu Motors Limited (Isuzu) is recalling certain 2022-2026 Isuzu FVR, 2023-2026 Chevrolet 7500XD, 2018-2026 Chevrolet 6500XD, and Isuzu FTR vehicles. The axle stabilizer bracket bolts may crack and break, allowing the bracket to detach from the vehicle.
Remedy: Dealers will replace the stabilizer bar brackets, free of charge. This is a Phased campaign. Phase 1 will include Class 6 vehicles (FTR, Chevy 6500XD).
Steering › Critical fasteners
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2018-2021 Isuzu FTR and 2018-2021 Chevrolet 6500XD vehicles. A bolt on the left front steering knuckle may come loose, resulting in an increased turning radius and difficulty steering to the left.
Remedy: Dealers will replace both right and left side stopper bolt jam nuts and clean or replace the extensions, as necessary, free of charge. Owner notification letters were mailed on February 28, 2022.
Electrical system › Starter assembly
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2018-2021 FTR and Chevrolet 6500XD vehicles. The ground cable connecting the starter motor to the vehicle frame may break at the starter-side eyelet, resulting in an engine no-crank or slow-crank condition, causing the vehicle not to start.
Remedy: Isuzu and Chevrolet will notify their respective owners and dealers to replace the ground cable and to inspect and replace the power steering hose is damage exists, free of charge. The recall began October 9, 2020.
Electrical system › Wiring
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2018-2020 FTR and Chevrolet 6500XD vehicles. The chassis wire harness outside the relay box may have been improperly routed, potentially allowing the harness to contact the suspension's leaf spring hanger bracket, allowing the harness to get chafed.
Remedy: Isuzu will notify owners, and dealers will repair or replace the existing wire harness, as necessary, and install additional clamps to ensure the wire harness is secured away from the hanger bracket, free of charge.
Steering
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2018-2020 FTR and Chevrolet 6500XD vehicles. The jam nut for the steering stopper bolt on the left front knuckle may loosen and allow the bolt to back away from the steering knuckle, increasing the turning radius of the vehicle in a left turn.
Remedy: Isuzu will notify owners, and dealers will replace the existing left and right jam nuts with a Grade 8 jam nut, torque the nut to a new torque specification and apply Loctite to the nut and bolt, free of charge.
Frequently asked questions
How many recalls does the 2019 Chevrolet 6500XD have?
There are 5 recalls for the 2019 Chevrolet 6500XD, the most recent from October 22, 2025 (hanger/bracket). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.