Which parts fail
Components named in complaints (fuel pump, injectors, fuel tank, hybrid and EV propulsion).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2008 Buick Lucerne owners, lightly cleaned up (personal details are redacted by NHTSA).
-The electrical system failed, causing the fuel pump to not work properly due to design flaw in the backseat putting pressure on the fuse box which is located under the backseat. The spot where contact is made to the fuse box, is where the fuel pump relay is. Pressure from the seat bracket (with or without a passenger in the seat) causes the pump replay to not make proper contact with the terminal, therefore causing the power to arc and get so hot that the relay starts smoking, melting the relay, fuse box and surrounding fuses and leaving black scorch marks on the inside of the lid to fuse box and making the car smell like burnt plastic. …
Fuse box (rear) 2008 Buick Lucerne CXL. FUEL PUMP Relay burns fuses out quickly. The fuse box located under the back seat has been having issues of burning where the fuel pump relay is located. It then in turn shorts out the fuse box which keeps needing to be replaced. This is a safety issue as it catches fire under the back seat. Fuse box has been replaced before and continues to have issues and melts, causing the vehicle to die in mid traffic, does at stop lights or even just parked and running it dies out and smells like burning plastic. The fuse box has caught fire several times. The issue has been confirmed by several mechanics and dealerships. Also there is a history of electrical problems with the rear fuse box in carfax. There was no warning, and now the check engine light is illuminated. We bought the vehicle last year in June of 2024. …
I went to start the vehicle and it failed to start. I found the fuel pump relay to be badly burned . On the 30 pin. The board was melted at the 30 pin spot for the fuel pump relay. I purchased a new relay from NAPA. I questioned whether they had a new replacement fuel pump. They told me it was not available only through the dealership. My concern was that where the relay was located at there was a possibility of a fire given how badly the relay and board was burned. I replaced the relay and purchased an extra incase this might happen again. To my surprise it happen just days later while I was driving on the expressway. I had to get off the road immediately. Engine died, no power steering. I checked the relay, it was smoking hot. I will have to have the problem resolved. There is no way a relay should ever get hot, let alone that hot. The fuel pump fuse was not effected. …
The fuel pump relay keeps getting hot and burning, causing the car to not start or loosing power while driving. Lost power going up a hill and around curve with no place to pull over. Could have been hit when car died in blind spot in road. Looked it up and other people on line are saying it is the seat clips hitting fuse box causing short circuit in fuse box and damaging fuse box. People said they thought it was fuel pump but still had same problem after replacing fuel pump. A lot of upset people on line saying there should have already been recall on this problem. Have had 2 mechanics look at it. Have bought 3 relays. Afraid to drive car if it will start, fear of loosing power in middle of road and getting killed. Not to mention could cause fire since fuse box and battery are under back seat.. Genius engineer, I'll tell you! Don't know if I can ever completely trust this buick again. …
Our Buick Lucerne would crank but wouldn't turn over when trying to start after trying to pick up take out. 1) It was suggested to me by a passerby that it sounds like a fuel pump relay. 2)I started to smell something burning. The passerby who happens to be familiar with Buick Lucerne tried to help. He lifted the back seat and showed me the fuel pump relay which was burned. Then he switched the electrick window relay which is the exact same relay switch and the car started. Went immediately to an autozone and bought spare fuel pump relay. Thought that solve the problem, but every 2 to 3 days I'd smell that burning smell. 3) The mechanic I've been going to for 10 years confirmed the issue 4)Have not taken to dealer or insurance rep 5)Absolutely no visual warning on dashboard. the warning happens when I start smelling the burning odor. Started one and a half months ago....
The rear fuse box burned out the fule pump relay because of the metal hooks for the seat hit it and pop the fuse out causing it to ark and burn out. I had to have the fule pump replaced twice as that what I was told at auto shops. Going on line was the only reason I found out about the fuse box. After my car died and wouldnt start, opened the casing and sure enough the fule pump housing was completely burned. So now after replacing two fule pumps my emergency money is gone and who knows how long it will before am able to buy a 400$ fuse box with probably another couple hundred in labor to change it out. All because there was to much metal on the seat hooks.
1. Fuse box was replaced, yes. 4th repair shop replaced. I say only time will tell for sure. i don't drive every day 2. driving I-95 from VA to MD at speeds of 30+ to 75+ cars driving close behind could have ran into rear causing my car, their car, and multiple other cars to be in major accident with possible multiple deaths. 3. reproduced, no. independent service center, no 4. No. Other - the 4th repair shop inspected vehicle component. 5. No warning lamps. No messages or symptoms, car just stalled and would not start/move and w hen I tried to start car again car would not start, but had all kinds of warnings lamps lit up. The first time the engine stalled was driving (moving) into entrance of toll booth in Richmond, VA, July 27, 2021 approx. 2:15 pm. …
Bought my car Sept. 2022.Within the first couple of months I started having intermittent problems that seemed fuel related.After some research I found out my car had a TSB that has been out since 2016. With this knowledge I took the back seat out of my car and the problems all stopped.June of 2023 started having some problems that were sort of similar to what I was experiencing before with some power loss, had vehicle taken to mechanic who diagnosed an interlock system problem.I thought maybe that would fix all my problems and put my back seat back. I travel 4 hours once a month to go see my son and only took my car once on that trip because of not being able to have a back seat.Me thinking the interlock fix was the solve all to my problems I put the back seat in and started my drive to go see my son. 3 hours in stop for gas, try to start my car, cranks won't start, not getting fuel. …
Tl* the contact owns a 2008 Buick Lucerne. The contact stated that the vehicle was at stand still at a hospital parking lot, when he entered the vehicle and detected plastic burning odor as the vehicle failed to start. The vehicle was not drivable and towed to his residence. The contact called an independent mechanic and was informed that the electronic fuel pump was needing to be replaced. Upon investigation, the contact read a technical service bulletin from general motors on-line on how to replace the electronic relay module and replaced the part on his own. The contact stated he experienced the failure again on December 16, 2019. The manufacturer had been informed of the failure. The vehicle was not diagnosed or repaired as of yet. A dealer was not contacted. The failure mileage was 125,000.
Tl* the contact owns a 2008 Buick Lucerne. The contact stated while driving at an unknown speed, the vehicle stalled with no warning. The vehicle was unable to restart and towed to a truck stop. The contact stated that upon investigating the failure, discovered that the fuel pump relay was melted and burnt. The contact stated that prior to the discovery no smoke or fire was noticed under the rear seat where the fuel pump relay was located in the fuse box. The contact stated he purchased and replaced the part himself. The vehicle was able to start and the vehicle was driven to the contact's residence. The vehicle was not taken to an independent mechanic or dealer for diagnosis or repairs. The manufacturer was not made aware of the failure. The approximate failure mileage was 211,000.
Fuel System complaints in other Lucerne years
Frequently asked questions
How common are fuel system problems on the 2008 Buick Lucerne?
NHTSA has 62 complaints about the fuel & propulsion system of the 2008 Buick Lucerne, 28% of the model year's 218 complaints. The component named most often is delivery › fuel pump (6 mentions).
Is there a recall for 2008 Buick Lucerne fuel system problems?
No. NHTSA lists no fuel & propulsion system recall for the 2008 Buick Lucerne, though it has 3 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2008 Buick Lucerne fuel system problems start?
Half of the complaints with a recorded mileage happened before about 86,000 miles, and 14% before 25,000 miles.
Is it dangerous?
Owners linked 1 crash, 11 fires and 1 injury to fuel & propulsion system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.