Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 BMW X3 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2020 BMW X3. The contact stated that after parking the vehicle and turning the engine off, approximately 10 minutes later a burning rubber odor was present inside the cablin of the vehicle and smoke was present coming from under the hood. The contact opened the hood discovered flames coming from the engine. The fire and police departments were called to the scene and the fire was extinguished the flame. During the incident the vehicle destroyed and later lowed away. A fire and police report was taken. No injuries were reported. The cause of the fire was not yet determined. The manufacturer was notified of the incident. The local dealer was not contacted. The contact was informed that the VIN was not included in the NHTSA Campaign Number: ( ). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 65,000.
The contact owned a 2020 BMW X3. The contact stated that while her husband was driving 10-15 MPH in a parking lot and attempting to make a turn, the brake pedal was depressed, but the pedal travelled down to the floor, and the vehicle failed to respond. Additionally, the steering wheel seized, and the accelerator pedal was depressed, but the pedal travelled down to the floorboard, and the vehicle failed to respond. The contact stated that the vehicle became inoperable, causing the front driver's side bumper and door of the vehicle to crash into the rear-end of an unoccupied parked vehicle, and then the front end of the vehicle crashed into the side of another occupied parked vehicle. All the air bags of the vehicle deployed. There were no injuries sustained. A police report was filed. …
The contact owns a 2020 BMW X3. The contact stated that while driving at an undisclosed speed, the emergency sensor warning light illuminated, as well as the camera system, the Forward Collision Avoidance warning light, and the key proximity features malfunctioned. The contact stated that the shark fin cover was missing from the vehicle. The vehicle was taken to the dealer, where it was diagnosed, and determined that the backup battery and wiring harness were damaged due to water intrusion from the missing shark fin cover. The contact was informed that the backup battery, wiring harness, and shark fin cover need to be replaced; however, the vehicle remained unrepaired. The contact had contacted the insurance provider, and the insurance provider declined to cover the repairs under the comprehensive coverage, citing that the failure was a known issue with BMW vehicles. …
The contact owns a 2020 BMW X3. The contact stated that the vehicle hesitated while starting. The contact then stated that while at a relative's home, the vehicle failed to start after multiple attempts, with white colored smoke coming from the vehicle. There was no warning light illuminated. The contact used a code reader and retrieved DTC: 216113, 21611A, 21A511, and 216115. Due to the failure, the vehicle remained at the relative's home. Upon investigation, the contact discovered NHTSA Campaign Number: 25V636000 (Electrical System); and linked it to the failure. The manufacturer and the dealer were notified of the failure and confirmed that the vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 90,500.
The contact owns a 2020 BMW X3. The contact stated that while driving 25 MPH, the message "Heat Management Module Malfunction" was displayed and the warning light was illuminated. The drive-train warning light was illuminated. Upon research, the contact became aware of NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The vehicle was previously taken to the dealer to be diagnosed, and the contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no additional assistance was provided due to a prior good-faith repair being provided. The failure mileage was approximately 70,000.
The contact owns a 2020 BMW X3. The contact stated that upon starting the vehicle, there was an abnormal thumping sound coming from the vehicle. There was no warning light illuminated. The contact later received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The vehicle was taken to a local dealer, and the contact was informed to leave the vehicle at the dealer overnight. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The vehicle was not repaired. The failure mileage was approximately 60,000.
The contact owns a 2020 BMW X3. The contact stated while driving at an undisclosed speed, the brake pedal was released, the auto start feature failed to function as intended. The vehicle was taken to the dealer where it was diagnosed with a failed engine starter. The contact was informed that the engine starter needed to be replaced. The vehicle was not repaired. The contact referenced a recall, NHTSA Campaign Number: 25V636000 (Electrical System) however the contact's VIN was not associated. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 55,000.
The contact owns a 2020 BMW X3. The contact stated that several attempts were needed while cold-starting the vehicle. The contact stated that prior to receiving notification of NHTSA Campaign Number: 25V636000 (Electrical System); the battery was replaced; however, the vehicle was still difficult to start. The local dealer was contacted, and the contact was informed that the remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 51,000.
The contact owns a 2020 BMW X3. The contact stated that while driving at an undisclosed speed, the drivetrain warning light illuminated on the instrument panel, causing the vehicle to jerk and run rough. The vehicle was taken to the dealer, where it was diagnosed with a heat management module failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 53,404.
On August 31, 2020, I purchased a new 2020 BMW X3E, manufactured and warranted by BMW, from Habberstad BMW, located at 945 East Jericho Turnpike, Huntington Station, New York 11746. On or about October 14, 2020, I was notified by a BMW Safety Recall regarding a defective battery in my hybrid vehicle. I later learned that on or about September 2, 2020, BMW submitted a Part 573 Safety Recall Report to the NHTSA, that on August 11, 2020, BMW decided to conduct a voluntary safety recall, and that per the Safety Recall in August 2020, BMW dealerships were expressly told NOT to sell any new motor vehicles that were subject to this recall. Thus, when I purchased my new vehicle, BMW and the dealership knew about the safety recall and they still sold me the vehicle. …
Related recalls
Electrical system › Starter assembly › Relay
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026.
Electrical system › Propulsion system › Traction battery
BMW of North America, LLC (BMW) is recalling certain 2020-2021 530e, 530e xDrive, 530e iPerformance and X3 xDrive30e and MINI Cooper Countryman All4 SE, 2020 BMW i8, and 2021 330e, 330e xDrive, 745Le xDrive and X5 xDrive45e vehicles. Debris may have entered one or more of the hybrid battery cells during their production.
Remedy: BMW will inspect and, if necessary, replace the battery module free of charge. The remedy is currently being developed. Until the remedy is completed, drivers are instructed to not charge their vehicles.
Electrical system › Propulsion system › Traction battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020.
Electrical complaints in other X3 years
Frequently asked questions
How common are electrical problems on the 2020 BMW X3?
NHTSA has 35 complaints about the electrical system of the 2020 BMW X3, 32% of the model year's 110 complaints.
Is there a recall for 2020 BMW X3 electrical problems?
Yes — NHTSA recall 25V-636 (relay, Sep 23, 2025); NHTSA recall 20V-601 (traction battery, Sep 30, 2020); NHTSA recall 20V-490 (traction battery, Aug 18, 2020). Recall repairs are free at authorized dealers.
At what mileage do 2020 BMW X3 electrical problems start?
Half of the complaints with a recorded mileage happened before about 55,000 miles, and 31% before 25,000 miles.
Is it dangerous?
Owners linked 2 crashes, 1 fire and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.