Most common 2007 BMW 530xi problems
Share of the 67 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
BMW 530xi complaints by model year
2007 BMW 530xi recalls (1)
Air bags › Sensor › Occupant classification
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model…
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant…
What 2007 BMW 530xi owners say
Engine & cooling
The contact owns a 2007 BMW 530XI. The contact stated that while driving in the snow, the vehicle overheated. The contact was able to pull over to the shoulder. The engine overheated, and slow-down messages were displayed. The engine overheated and shut down immediately. warning indicator lights were illuminated. The vehicle was towed to the local dealer where it was diagnosed that the thermostat and water pump needed to be replaced but the dealer refused to repair the vehicle. The vehicle was not repaired. The vehicle was towed to the contact's residence. The manufacturer was notified about the failure and referred the contact to the dealer. The contact stated the failure was related to NHTSA Campaign Number: 22V119000 ( Engine and Engine Cooling). The approximate failure mileage was 178,000.
The contact owns a 2007 BMW 530XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the vehicle was overheating while driving. The contact stated that the frame of the vehicle felt extremely hot after driving and the vehicle took a long time to cool down. There was no warning light illuminated. An unknown local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 100,000. VIN tool confirms parts not available.
Electrical system
The front Xenon Headlight Wiring protective plastic coating has degraded and prematurely failed on both headlight assemblies. This caused headlight bulb shorting and poses a potential fire hazard in the front engine compartment of the vehicle. The wiring used in the headlight assemblies was not up to proper standards and failed. The wiring used in other areas of the engine bay seems to be okay. The internal headlight wiring appears to be supplied by the OEM Headlight Manufacturer (HELLA) and does not seem to be up to proper standards to prevent the plastic protective coating from failing over time. This should not be considered a "wear item" as electrical wiring is used throughout millions of much older vehicles without incident.
in the trunk in the spare tire well. Water could be there, flooding some electronics. The wiring got wet causing my car to just turn off in the expressway due to the comments getting wet that are harnessed in this area. I tried to get it repaired when the class action lawsuit took place but the dealership I had my car at for 3 months never performed the repair. Then the next dealership refused to perform the repairs due to time constraints. Now every time it rains I am worried my car will short or just shut off. I have had to replace the part 2 times and now I just leave it unattached . the BMW agrees to settle vehicle water damage suit for up to $478 million. WASHINGTON (Reuters) - German automaker BMW AG has agreed to pay up to $477.7 million to settle a class-action lawsuit covering about 318,000 U.S. …
Air bags
The contact owns a 2007 BMW 530XI. The contact stated that while driving at 35 MPH, the front driver's side air bag deployed without an impact. The contact had not sustained any injuries during the failure. Despite the failure, the contact was able to drive the vehicle back to the residence. The local dealer was notified of the failure, and the vehicle was towed to a dealer. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 172,000.
The contact owns a 2007 BMW 530XI. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 13V564000 (Air Bags) however, the VIN was not included in the recall. The failure mileage was approximately 150,000.
2007 BMW 530xi engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 3.0L 6-cyl | 6-speed manual | 4WD/AWD | 17 / 26 / 20 |
| 3.0L 6-cyl | 6-speed automatic | 4WD/AWD | 17 / 25 / 20 |
EPA ratings. Class: Midsize car.
Frequently asked questions
Is the 2007 BMW 530xi a good car?
There isn't enough complaint history for the 530xi to compare model years reliably. So far owners have filed 67 complaints with NHTSA.
What is the most common problem with the 2007 BMW 530xi?
The engine & cooling — 18 complaints, 27% of all complaints for this model year, most often about cooling system › radiator assembly. Next are the electrical system (17) and air bags (13).
How many recalls does the 2007 BMW 530xi have?
There is 1 recall for the 2007 BMW 530xi, the most recent from November 12, 2013 (occupant classification). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
At what mileage do 2007 BMW 530xi problems happen?
The median mileage reported in complaints is about 83,000 miles; 23% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.