Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 BMW 528xi owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2012 BMW 528XI. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); and the vehicle was taken to the dealer for the recall repair. The contact was informed that the recall repair had been performed. The contact stated that upon driving off the parking lot at the dealer and coming to a complete stop at the traffic light, the message "Drive Train Malfunction - Service to Nearest BMW Dealer as Convenient" was displayed. Additionally, the vehicle was significantly sluggish and failed to respond upon depressing the accelerator pedal. …
The contact owns a 2012 BMW 528XI. The vehicle was previously repaired under NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM), but the failure occurred. The contact stated that while driving at an undisclosed speed, the check coolant level warning light illuminated. The vehicle was taken to the dealer. The contact was informed that the recall repair was not yet available. However, the dealer installed a splash seal. The contact notified the manufacturer of the issue, and was referred to contact another dealer since parts for the recall repair were available. The vehicle was taken to a different dealer where the remedy was available, and the contact was informed that the recall was already completed. The vehicle was not repaired. The contact stated that the failure persisted. …
The contact owns a 2012 BMW 528XI. The contact stated that while driving at various speeds, there was a misfire coming from the engine with the "Drivetrain Malfunction" message displayed. The contact later received a notification for an unknown recall, and a diagnostic test was performed however, no failure was found for the drivetrain. The recall repair was performed. Recently, the contact stated that the vehicle would shut off soon after it was started. The vehicle was taken to an independent mechanic where a diagnostic was performed; the diagnostic test discovered that the camshaft sensor was fractured, and metal shavings were found in the oil pan. The vehicle was then diagnosed with engine failure. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 128,900
The contact owns a 2012 BMW 528XI. The contact stated that while driving at an undisclosed speed, the vehicle came to a stop and the Automatic START/STOP feature activated; however, the engine failed to restart. The message "Drive Train Malfunction Error" was displayed. The vehicle was towed to the dealer, who determined that the timing chain had fractured, causing unknown parts to enter the engine. The contact was informed that the timing chain needed to be replaced. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 119,000.
in 2020 the engine started malfunctioning at 76,000 miles. I took it into the BMW dealership to get it inspected and they stated that it was a valve issue and charged replacement. After replacement, the engine lit would come on and I called the representative. He stated that it would need time to reset so I continued driving it. Eventually the light did not come on for some time. A year later in 2021 after driving to work the engine started to stall on my way to work on the highway. I since taken it back to BMW stating that it was less than 10,000 miles since the repair and I'm having engine troubles again. After talking to the BMW service representative, they stated that I will need a new engine because it is now blown. The engine only has 84,000 miles on it and I requested root cause analysis on the engine. …
The vehicle suffered a sudden Drivetrain Malfunction and severe engine overheating while driving, resulting in a physically snapped camshaft and extensive iron shaving contamination in the oil pan (catastrophic engine failure).Ten months ago, an authorized dealership performed the official BMW Water Pump Safety Recall (NHTSA Campaign 24V608000). The vehicle has an active history of drivetrain malfunction fault codes dating back to January 2024. The failure of the recall remedy to safely maintain the cooling loop directly caused severe thermal stress and lubrication breakdown, leading to the camshaft fracturing. …
While driving on the Grand Central Plwy, Queens, NY, a drive train motification came on and stated to drive moderately, right after the oil light came on. We were near a gas station, and added a quart of oil. The oil light went out, the car started without hesitation. We decided to go home, we got off the highway about a mile out, the car just stopped went into park and could not start again. It would crank over, but not connect. We were on a four lane road, luckily there was no one behind us, it could have been a terrible incident. The car was towed to a BMW dealership in Great Neck, NY and we were told it was either the engine or the timing chain and it was not worth fixing. The car was then towed to my mechanic, who stated there was a technical warning #N20 & N26 regarding the timing issue. Hoping something can be done
Car gave a Drivetrain Malfunction error and I was able to get the car to the mechanic I've used on the car since it was purchased. I was informed this week that there is now debris in the oil from the timing chain.
Car just wouldn't start one day. Drivetrain malfunction warning indicating timing chain replacement. Car just sits in my driveway. Will cost 6 grand to fix. Timing Chain failure probably effected my engine.
While driving my car at about 30 miles per hour the engine suddenly seized up. There was no warning at all. I had it towed to the dealer, Baron BMW in Merriam Kansas. After evaluating the car they determined the engine failed and it was an issue of lack of oil. I had taken the car to this dealer prior to buying the car to make sure there were no problems. After their inspection I went ahead and bought the car. It had 40,528 miles. I had taken it to the same dealer for service for 3 years prior to the engine failure When the engine failed the mileage was 95,444. I talked with the dealer and let them know that I felt BMW should pay for replacement of the engine. They refused to do this so I was stuck with having to pay for another engine. After researching this issue I found out that there numerous issues with the engine and that several people had had the same problem. …
Engine complaints in other 528xi years
Frequently asked questions
How common are engine problems on the 2012 BMW 528xi?
NHTSA has 33 complaints about the engine & cooling of the 2012 BMW 528xi, 61% of the model year's 54 complaints.
Is there a recall for 2012 BMW 528xi engine problems?
No. NHTSA lists no engine & cooling recall for the 2012 BMW 528xi. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 BMW 528xi engine problems start?
Half of the complaints with a recorded mileage happened before about 91,000 miles, and 8% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.