Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2012 BMW 528i owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2012 BMW 528i. The contact stated that while the vehicle was parked, the vehicle was started, however, the vehicle failed to start. The contact stated the vehicle eventually started. In addition, the contact stated that when the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the steering wheel seized and the vehicle lost motive power. The vehicle was towed to the contact's residence. The dealer was made aware of the failure and confirmed that the parts were not available. In addition, the contact stated that previously the vehicle was taken to the dealer where it was diagnosed with a failed coolant pump and unknown sensor. The contact was informed that the coolant pump and the unknown sensor needed to be replaced. …
The contact owns a 2012 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact stated that while the vehicle was parked, there was condensation underneath the vehicle. The contact stated that while driving approximately 50 MPH, the "Engine Malfunction" message was displayed, and the vehicle stalled. The vehicle was restarted 20 minutes later after several attempts. The failure reoccurred several times until the vehicle was taken to the residence and parked. The vehicle was towed to a dealer where it was diagnosed that the control unit seal pump needed to be replaced. The vehicle was repaired but the failure persisted. …
The contact owns a 2012 BMW 528I. The contact stated while the vehicle was parked, the vehicle failed to start. The contact attempted to restart the vehicle. After several attempts, the vehicle failed to start. Several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that on another occasion, while driving 60 MPH, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the residence. The vehicle was then towed to the contact's office. An independent mechanic arrived and diagnosed the vehicle with engine failure. The vehicle was not repaired. The manufacturer was notified of the failure. …
The contact owns a 2012 BMW 528i. The contact stated while driving approximately 35 MPH, there was an abnormal sound coming from the vehicle. The drivetrain malfunction warning light illuminated. The vehicle was towed to an independent mechanic and diagnosed with a defective oil pump. The vehicle was repaired. The contact related the failure to NHTSA Campaign Number 14V176000 (Engine and Engine Cooling). The manufacturer was not notified of the failure. The approximate failure mileage was 109,000.
Car engine caught on fire while driving today and stopped. No smoke or other issues prior. Worried this is related to the recall issued by BMW recently, however my car is not covered under the recall yet. The car is currently located in Vancouver Canada. It was purchased in Tulsa, OK
Casually picking up from a stop light when my car just randomly decided to turn off on the middle of the road and go into neutral. I lost power steering and brakes. I was able to manage to pull over and restart the car and I was welcomed with a bunch of check engine lights and many other malfunctions. Got the car towed and comes out that the timing chain has failed as well as the oil pump and resulted in damage to the camshaft and cylinder head of the motor. This is just insane how all of this happened in just a few seconds. I took care of my car did oil changes on time, coolant, brakes, transmission fluid. I took care of my car. Bmw put me in a very unsafe condition that day and I'm very upset because that could have ended very bad for me. The n20 motor has been very well known to fail at any time without any warning and bmw has yet to recall this motor. …
The contact owns a 2012 BMW 528I. The contact stated that there was water leaking from the vehicle. There was an undisclosed electrical failure. The contact stated that the vehicle was consuming an excessive amount of engine oil. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
The drivetrain disintegrated. Car started running really rough, and then just stopped completely. Would crank but would not move. Yes, it is available. Car would barely go, and then just stopped in the road. I had to have it towed to a mechanic. No, I had not received a warning of this possible hazard. No, it was not inspected by any of the above, but was inspected by numerous mechanics. Yes, drivetrain light/warning came on, as well as, drive at a slower rate when the car started to drive roughly. The turbo also went out on the car. May 28, 2024
I had just purchased a car but a month ago I was driving to lunch and I was at a stop sign when the light turned green I started to go the car started shaking and smoke was coming out of the front under the hood I had just an oil change so I took it back to the oil change shop. They could not figure out why the engine blew and I had to take it to a different BMW shop where I have to purchase a rebuilt motor and pay for the repairs. I can request all records from the automotive shop if needed.
car engine timing chain guides are faulty and there have been lawsuits that were settled and no recall on the actual part with drivers still having issues with the N20 engine now getting quotes for over $15,000. is this not an incident where it's not the fault of a driver but manufacturing? This needs to become a recall for all N20 engine timing chain and guides as the faulty part is causing complete engine failure. seems very deceptive when a BMW only last 100,000 miles.
Engine complaints in other 528i years
Frequently asked questions
How common are engine problems on the 2012 BMW 528i?
NHTSA has 48 complaints about the engine & cooling of the 2012 BMW 528i, 53% of the model year's 90 complaints.
Is there a recall for 2012 BMW 528i engine problems?
No. NHTSA lists no engine & cooling recall for the 2012 BMW 528i, though it has 4 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2012 BMW 528i engine problems start?
Half of the complaints with a recorded mileage happened before about 83,000 miles, and 9% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 3 fires and 0 injuries to engine & cooling problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.