What gets recalled
1996 Volvo Fe recalls (3)
Suspension › Front › Springs › Air suspension › Lines and fittings
Vehicle description: class 8 heavy duty trucks. The air suspension control valve supply line was not plumbed through an air pressure protection valve. In the event of a failure, there would be loss of air pressure in the 'b' system air reservoir that supplies air pressure for the front steer axle brakes.
Remedy: Dealers will install the necessary air pressure protection valve.
Service brakes, air
The traction solenoid exhaust can be obstructed due to inadequate drainage and a build-up of road contamination between the mounting bracket and the solenoid housing. The obstructed exhaust prevents the relay valve control air pressure from venting after a differential braking traction event.
Remedy: Dealers will remove the suspect valve and install a new valve that has a modified solenoid housing which will allow for sufficient drainage and a new valve mounting bracket with increased height to reduce entry of…
Steering › Linkages
Vehicle description: heavy duty class 8 vehicles built with a Volvo 5.7 (12,500 lbs) front steering axle. Due to hydrogen embrittlement, the front steering axle king pins could have broken during assembly. Continued operation of a vehicle with a broken king pin could allow the pin to work loose.
Remedy: Dealers will inspect the vehicles for a broken king pin and replace the king pins if broken.
1995 Volvo Fe recalls (5)
Suspension › Front › Springs › Air suspension › Lines and fittings
Vehicle description: class 8 heavy duty trucks. The air suspension control valve supply line was not plumbed through an air pressure protection valve. In the event of a failure, there would be loss of air pressure in the 'b' system air reservoir that supplies air pressure for the front steer axle brakes.
Remedy: Dealers will install the necessary air pressure protection valve.
Service brakes, hydraulic › Foundation components
The rear most axle of the tandem axle set could have inoperable brakes on one or both wheels because the brake s-cam was incorrectly installed.
Remedy: Dealers will inspect the brake system and repair the s-cam assembly if found reversed.
Service brakes, air
The traction solenoid exhaust can be obstructed due to inadequate drainage and a build-up of road contamination between the mounting bracket and the solenoid housing. The obstructed exhaust prevents the relay valve control air pressure from venting after a differential braking traction event.
Remedy: Dealers will remove the suspect valve and install a new valve that has a modified solenoid housing which will allow for sufficient drainage and a new valve mounting bracket with increased height to reduce entry of…
Suspension › Rear › Springs › Air suspension system
The rear suspension axle retention plate can break under normal use, affecting axle alignment.
Remedy: Dealers will remove and replace the axle retention clip plates on affected vehicles.
Show 1 more recall
Steering › Linkages › Arm › Idler and attachment
Two bolts attaching the upper steering arm to the front steering axle were not tightened properly.
Remedy: Dealers will install new bolts and tighten to proper torque specification.
Frequently asked questions
How many recalls does the Volvo Fe have?
NHTSA lists 6 recalls for the Volvo Fe across 2 model years.
How do I know if my Volvo Fe has an open recall?
Enter your 17-character VIN in our VIN decoder & recall check or on nhtsa.gov/recalls. Dealers fix recalls for free, even if you are not the original owner.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.