What gets recalled
1997 Volvo 854 recalls (2)
Seats › Front assembly › Seat heater/cooler
On some sedans and station wagons equipped with seat heaters, it is possible that excessive compression of the seat cushion could cause damage to the electrical wiring of the seat heater.
Remedy: Dealers will disconnect the existing wires and install a new electronic thermostat and cable harness. Owner notification began on February 19, 2003.
Vehicle speed control
The screws which attach the throttle plate to its axle (shaft) can loosen allowing the throttle plate to come in contact with the throttle housing.
Remedy: Dealers will replace the throttle housing.
1996 Volvo 854 recalls (2)
Seats › Front assembly › Seat heater/cooler
On some sedans and station wagons equipped with seat heaters, it is possible that excessive compression of the seat cushion could cause damage to the electrical wiring of the seat heater.
Remedy: Dealers will disconnect the existing wires and install a new electronic thermostat and cable harness. Owner notification began on February 19, 2003.
Vehicle speed control
The screws which attach the throttle plate to its axle (shaft) can loosen allowing the throttle plate to come in contact with the throttle housing.
Remedy: Dealers will replace the throttle housing.
1995 Volvo 854 recalls (2)
Seats › Front assembly › Power adjust
The threaded insert which attaches the safety belt catch to the front seat was incorrectly manufactured.
Remedy: Dealers will replace the threaded insert in the affected front seats.
Equipment › Mechanical › Accessory scissor/screw/bottle jack/lift
Some of the jacks supplied with the vehicles do not have the necessary load capacity.
Remedy: Dealers will inspect and replace suspect jacks with a jack meeting the load requirements for these cars.
Frequently asked questions
How many recalls does the Volvo 854 have?
NHTSA lists 4 recalls for the Volvo 854 across 3 model years.
How do I know if my Volvo 854 has an open recall?
Enter your 17-character VIN in our VIN decoder & recall check or on nhtsa.gov/recalls. Dealers fix recalls for free, even if you are not the original owner.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.