Most common 2005 Toyota Sequoia problems
Share of the 352 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Toyota Sequoia complaints by model year
Best Sequoia years: 2009, 2015, 2017. Years to avoid: 2004, 2005, 2007, 2006, 2008. Compare all years →
2005 Toyota Sequoia recalls (9)
Air bags › Frontal › Driver side › Inflator module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430,…
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator.
Air bags › Frontal › Passenger side › Inflator module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator,…
Seats › Front assembly › Seat heater/cooler
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010…
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016.
Air bags › Side/window
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016.
Air bags
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory.
Air bags
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii,…
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory.
Show 3 more recalls
Seats › Front assembly › Seat heater/cooler
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge.
Equipment › Other › Labels
Southeast Toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on May 27, 2010.
Suspension › Front › Control arm › Lower ball joint
On certain trucks and Mini vans, due to possible improper finishing of the front suspension lower ball joint, some ball joints May experience an incidental deterioration of the internal lubrication.
Remedy: Dealers will replace the front suspension lower ball joints. The recall began on February 28, 2007. Owners May contact Toyota at 1-800-331-4331.
NHTSA defect investigations
Federal safety investigators have looked into 4 possible defects involving the 2005 Toyota Sequoia:
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag…
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited.
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag…
Lower ball joint failure
In a letter dated January 18, 2007, Toyota notified NHTSA of a safety defect in model year (my) 2004 through 2006 Toyota tundra and my 2004 through 2007 Toyota sequoia vehicles produced between September 15, 2003 and November 17, 2006 (NHTSA recall no. 07v-013).
What 2005 Toyota Sequoia owners say
Stability & traction control all 110 →
A couple of days ago, when I was driving on the highway, my Sequoia suddenly stopped accelerating. Trac light and vsc light and check engine light came on. My speed would not go above 40mph and would not even brake. I was in the left lane and the cars behind me were going pretty fast and almost hit me. I am lucky there was no car in the right lane, so I pulled to that lane just in time. It was a scary moment for me because my kids were with me also. I always thought of Toyota of having safety in their cars, but when I came home to research what might be happening to the car, I found out many people are having the same exact problem and thus it is a manufacturers problem. I am suprised Toyota is not doing anything about this. Do they not care of the safety of the consumers? The milage on my Sequoia is only 39,000 and I do not drive it too often, and also have maintained it very well. …
While driving at 35 MPH, the check engine light, vsc off light, vsc trac light, and the emergency brake light all came on at once, and the vehicle stopped accelerating, and I experienced a dramatic decrease in vehicle power. I drove the vehicle home noticing a drastic change in acceleration as the Sequoia would not accelerate normally; it would accelerate at a significantly reduced rate, topping out at 35mph on the flats, 30 MPH on an incline, I was able to reach 70mph going down hill on a highway. Since that day, during start up, the engine makes a high-pitch vacuum noise, which drops off and normal engine sound returns. All dashboard lights are normal, until 10-15 seconds after start, when the vsc off/vsc trac/brake lights all illuminate, and remain on until the engine is turned off and the poor acceleration and decrease power are now the norm. …
Brakes all 91 →
I tried to make apointments to local dealers they set up appointments and than don't do nothing about it they said the don't have any certified tech to do the job so I left with this mess not knowing when my ride is going to give. Out on me I got about 319000 miles Toyota should be proud and thank me for keeping my ride up to date I do my part to have it running good but they not doing there part to help me with these recalls please help me out.
After several years of fighting problems with, after braking to a brief stop, the loss of power/abs grinding when accelerating and turning right, now the ABS is completely dysfunctional. Both TRC lights will turn on and usually the parking brake, and when braking at speeds less than 10mph the abs will activate and prevent bring the truck to a stop without pumping them, on dry pavement. When the ABS light turns on, then braking is possible, but all pressure is gone from brake booster and brakes sound like they're grinding, not like the sound of abs engaging. Very dangerous to drive in snow as front brakes work but drive axle doesn't disengage when the brake pedal is depressed. Regular mechanic won't engage with diagnosing issues as he feels the problem is partly computer malfunction and Toyota won't allow for used part mismatching. ABS/ECU is failed.
Speed control & acceleration all 85 →
After several years of fighting problems with, after braking to a brief stop, the loss of power/abs grinding when accelerating and turning right, now the ABS is completely dysfunctional. Both TRC lights will turn on and usually the parking brake, and when braking at speeds less than 10mph the abs will activate and prevent bring the truck to a stop without pumping them, on dry pavement. When the ABS light turns on, then braking is possible, but all pressure is gone from brake booster and brakes sound like they're grinding, not like the sound of abs engaging. Very dangerous to drive in snow as front brakes work but drive axle doesn't disengage when the brake pedal is depressed. Regular mechanic won't engage with diagnosing issues as he feels the problem is partly computer malfunction and Toyota won't allow for used part mismatching. ABS/ECU is failed.
Malfunction indicator lights - Check engine, VSC off and TRAC off. The vehicle goes into limp mode. The issue is both a mechanical and engineering defect causing the override of the entire AIP system. Parts affected are Air injection pumps, Air switching valves, Air pump inlets/covers, Gaskets/connectors/clamps and Speed sensors.
2005 Toyota Sequoia engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 4.7L 8-cyl | 5-speed automatic | RWD | 14 / 17 / 15 |
| 4.7L 8-cyl | 5-speed automatic | 4WD/AWD | 13 / 16 / 15 |
EPA ratings. Class: SUV.
Frequently asked questions
Is the 2005 Toyota Sequoia a good car?
Based on 352 owner complaints filed with NHTSA, the 2005 Sequoia rates avoid: 9.2× as many complaints as a typical year of the Sequoia at the same age. It is one of the Sequoia years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2005 Toyota Sequoia?
The stability & traction control — 110 complaints, 31% of all complaints for this model year. Next are the brakes (91) and speed control & acceleration (85).
How many recalls does the 2005 Toyota Sequoia have?
There are 9 recalls for the 2005 Toyota Sequoia, the most recent from October 17, 2019 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Toyota Sequoia?
The best years by complaints, compared at the same age, are 2009, 2015 and 2017. Years to avoid or approach with caution: 2004, 2005, 2007, 2006 and 2008. See the full Toyota Sequoia years comparison.
At what mileage do 2005 Toyota Sequoia problems happen?
The median mileage reported in complaints is about 87,000 miles; 23% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.