Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2025 Tesla Model 3 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2025 Tesla Model 3. The contact stated that while coming to a stop at a traffic light, the vehicle's autopilot system became inoperable, and the vehicle unexpectedly accelerated up to approximately 13 MPH without any warning lights illuminated. The contact attempted to regain control of the steering; however, due to the failure, the vehicle collided with another vehicle, resulting in severe damage to the driver's side rear quarter panel, wheel, and tire. The contact stated that the air bags did not deploy during the incident. No injuries were sustained, and no medical attention was required. A police report was not filed. The contact expressed concern that the vehicle may present a potential safety hazard, as the failure had recurred on multiple occasions when attempting to drive the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. …
The contact owns a 2025 Tesla Model 3. The contact stated while his daughter was driving 30 MPH at night with Full Self-Driving(FSD) Supervised mode engaged, the vehicle suddenly made a left turn. The contact stated that the vehicle drove over a curb and onto the grass, and the vehicle drove into a residence's driveway, where the front of the vehicle crashed into the rear passenger's side of three unoccupied vehicles that were parked in the driveway. The front passenger's side and driver's side air bags deployed. The exterior hazard lights were illuminated. The contact's daughter did not sustain any injuries. A police report was filed but the contact did not have the police report information available. The vehicle was towed to a tow lot, where it was waiting to be picked up by a certified Tesla autobody repair shop. …
The contact owns a 2025 Tesla Model 3. The contact stated while driving with the Autopilot and Full Self-Driving and attempting to parallel park into a parking space when it made a sudden left turn and crashed into a curb. The contact took over manually and depressed the brake pedal in order to avoid the entire vehicle driving over the curb. The contact mentioned that the Full Self-Driving software was the most updated version and it did not detect the curb causing the crash. The front passenger side bumper was damaged and scratches underneath the vehicle. No injuries were sustained. No air bags deployed. A police report was not filed. The Tesla Software did not detect the crash. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to take the vehicle to the dealer. The failure mileage was 19,000.
The reason that I'm currently writing you this letter is to report an incident that happened on Sep. 16th, 2025. This is the date that I was very excited because I got my first EV - Tesla Model 3 new car. Me and my wife went over to the delivery plant in Fefe, Washington. The address is 3701 20th St. E., Fife, WA 98424. We took the car and I myself drove it back home around 2:45ish (-3 :00 pm the latest). It was just two blocks away from the plant outbound to the eastward trying to get to the entry of the highway. I stopped my car on my brake, and suddenly my car went forward by itself. This unintended acceleration caused me to hit the car in front of me. We had to stop in the next parking lot on my left side as soon as we passed the traffic light. This intersection happened right at the intersection of 54th Ave. E (Northbound) and Pacific Highway E. I hit the car in front of me. …
The contact owns a 2025 Tesla Model 3. The contact stated that while driving on several occasions with Full Self-Driving (FSD) Mode engaged, the vehicle stopped abruptly while approaching a yellow traffic light, nearly causing the head of the driver to strike the windshield on one occasion. The contact stated that the vehicle failed to gradually come to a stop. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 10,100.
The contact owns a 2025 Tesla Model 3. The contact stated that on several occasions while driving with Full Self-Driving (FSD) mode engaged and approaching a closing gate, the vehicle failed to come to a complete stop. The failure required manual driver intervention to prevent a crash. The manufacturer was contacted but was not notified of the failure. The failure mileage was 15,000.
On [redacted], at just 9,526 miles, my brand-new 2025 Tesla Model 3 (VIN: [redacted] ) suffered a front motor/inverter failure. The vehicle displayed the warning "Front Motor Disabled." Tesla Vallejo Service confirmed this and replaced the front drive inverter (3DU). A catastrophic drivetrain failure at under 10,000 miles is unacceptable and raises serious concerns about reliability and safety. It still doesn't not accelerate as before. In addition, since delivery on [redacted], this vehicle has had persistent rattling and vibration issues in the cabin. I have returned to Tesla Vallejo multiple times (April, June, July, and August 2025). Each time, the service manager, Steve McNerney, dismissed or minimized my concerns, blaming "seatbelt rattling" or claiming the issue could not be replicated. …
After disengaging Full Self-Driving (FSD), a mandatory questionnaire pop-up now stays on screen until manually answered, instead of auto-dismissing after a few seconds as it previously did. This forces the driver to interact with the touchscreen immediately after taking back manual control - a moment when full attention should be on the road, not a pop-up. The prompt blocks part of the instrument/display screen until it is tapped, and in some cases requires a minimum 5-second voice response to dismiss (a previous workaround allowing a near-instant voice note to clear it was removed). The pop-up has also been observed persisting even after the vehicle is shifted into Park. This creates a distraction risk during an already safety-critical moment (immediately following a system disengagement, which by definition means FSD failed to handle the driving task). …
While operating the vehicle at low speed (~35 MPH reducing to a stop) on August 1, 2026, at approximately 10:38 AM under normal road and weather conditions, the vehicle experienced a catastrophic and simultaneous loss of primary braking capability and steering responsiveness. > Detailed Description of Failure: > * Brake Failure: Upon pressing the brake pedal, the vehicle failed to decelerate or stop adequately despite continuous application, nearly causing a collision. > * Steering Loss / Disconnection: Concurrently, while the steering wheel could physically be turned, it offered no directional control-turning the wheel had no effect on the vehicle's path, feeling as if the steering linkage or assist was entirely disconnected or disengaged. …
Since leasing this car in April of 2025, it has been services 8 times totaling over 30 days of down time. The issues occured in order from oldest to newest/current: May of 2025 - Headliner trim falling down, unsuccessfully repaired by mobile technician June of 2025 - Windows stopped working. Center console door stopped shutting. Headliner still falling down. July of 2025 - Front wiring harness melted and took out the AC - the car didn't provide a single warning. The AC just stopped working. Passenger seat replaced for cosmetic defect August of 2025 - Continued issues with AC and turn signal buttons December of 2025 - Steering Wheel Rattle and Clunking, Suspension noises June of 2025 - Suspension still rough and making grinding noises, turn signal buttons still not functioning consistently, front passenger fold down mirror shattered because the passenger seat calibration allows it to …
Related recalls
Electrical system › Propulsion system › Fuses, relays, contacts, and shunts
Tesla, Inc. (Tesla) is recalling certain 2025 Model 3 and 2026 Model Y vehicles. The battery pack contactors may fail, causing a loss of drive power.
Remedy: Tesla Service will replace the battery pack contactors, free of charge. Owner notification letters were mailed December 9, 2025. Owners may contact Tesla customer service at 1-877-798-3752.
Electrical system
Tesla, Inc. (Tesla) is recalling certain 2024-2025 Model 3, Model S, 2023-2025 Model X, and Model Y vehicles. The computer circuit board may short, resulting in the loss of the rearview camera image.
Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Tesla will also identify any vehicles that experienced a circuit board failure, or stress that may lead to a circuit board failure, and replace the…
NHTSA investigations
Traffic safety violations while Full Self Driving ("FSD") is engaged
The Office of Defects Investigation ("ODI") is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute tra c safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a…
Actually Smart Summon sessions resulting in low-speed impacts.
On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property.
FSD Collisions in Reduced Roadway Visibility Conditions
The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla's Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system's ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond.
Compliance with Standing General Order 2021-01 Reporting Requirements
The Office of Defects Investigation ("ODI") has identified numerous incident reports submitted by Tesla, Inc. ("Tesla") in response to Standing General Order 2021-01 (the "SGO"), in which the reported crashes occurred several months or more before the dates of the reports.
Electrical complaints in other Model 3 years
Frequently asked questions
How common are electrical problems on the 2025 Tesla Model 3?
NHTSA has 22 complaints about the electrical system of the 2025 Tesla Model 3, 18% of the model year's 121 complaints. The component named most often is adas › autonomous/self driving (3 mentions).
Is there a recall for 2025 Tesla Model 3 electrical problems?
Yes — NHTSA recall 25V-690 (fuses, relays, contacts, and shunts, Oct 10, 2025); NHTSA recall 25V-002 (electrical system, Jan 6, 2025). Recall repairs are free at authorized dealers.
At what mileage do 2025 Tesla Model 3 electrical problems start?
Half of the complaints with a recorded mileage happened before about 12,000 miles, and 100% before 25,000 miles.
Is it dangerous?
Owners linked 6 crashes, 0 fires and 0 injuries to electrical system problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.