Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2020 Kia Telluride owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2020 Kia Telluride. The contact stated that four door belt molding trim pieces had become loose and unsecured, but the front driver's side door belt molding trim piece had become unsecured and detached from the vehicle. Additionally, the contact stated that while touching the unsecured molding, the arm became bruised and scratched. No medical treatment was required. The cause of the failures was not yet determined. The local dealer was contacted, but no assistance was offered. The manufacturer was not yet contacted. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V494000 (STRUCTURE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 30,000.
I am the owner of a 2020 Kia Telluride with less than 60,000 miles, and I am experiencing a significant issue with the paint peeling off the top of my vehicle. The car is always parked in a garage and only used for routine school pick-ups, with no incidents or accidents that could explain the peeling paint. After researching, I have discovered that this issue is a recurring problem for many Kia vehicles with the Snow White Pearl paint color. It is evident that this is a result of defective paint, and I am outraged that I am being quoted $3,500 to fix an issue caused by Kia's faulty materials. The peeling has spread to two different areas and worsens daily, further devaluing my vehicle through no fault of my own. …
The 2020 Kia Telluride has an issue with the metal window trim pieces. It was purchased as a Certified Pre-Owned vehicle and we have had to have the trim piece replaced at least three times by the Kia Dealer. The piece keep becoming loose and falling off. Some of the pieces on my vehicle have jus fallen off. At interstate speeds of 70 MPH it would be very dangerous. Fortunately, no incident has happened that has hurt anyone, yet. The 2023-2025 models have been recalled for this exact same issue, and it needs to happen for ALL Kia Telluride models including the 2020-2023 models. It is dangerous and Ken Ganley Kia of New Port Richey is no longer assisting with any sort of warranty or repair unless I do the work. I am having to reach out to Kia and open a case number every time and the dealership is no longer being helpful. …
The power sunroof and its sliding track/rail assembly failed. While operating the sunroof using its normal electric open/close function during highway driving, the sunroof glass/panel traveled to full open and the track mechanism broke at that point, preventing normal closure. The vehicle and damaged sunroof/track assembly are available for inspection upon request. The failure occurred while the vehicle was in motion on the road, creating a distraction and an unexpected open aperture in the roof at highway speed. An uncontrolled/stuck-open sunroof exposes the cabin to wind, debris, weather, and noise, and could distract the driver attempting to address the malfunction while driving. There is also risk of glass or track hardware detaching from the vehicle. …
The wind deflector/bug guard on the sunroof broke and pieces from the broken mechanism proceeded to lodge themselves throughout the track of the sunroof causing the entire track system to break/malfunction. There are several screws that were snapped from the plastic track, which then left the sunroof glass "bouncing" and unsecured on the car. If this was not noticed prior to hitting the highway or driving with any sort of speed I am confident the sunroof would have shattered causing a hazards for myself and children in the vehicle or flown off the car causing a hazard to others on the road. The car is currently at a KIA dealership being looked at, to which they suggested this because it's becoming more and more "common". Additionally it is not a cheap fix, quoted just under $4000 for parts and labor. …
The original Telluride muffler developed a hole in the rear wall, hidden by the exhaust pipes. Within a week of the noise being noticeable I visited a car wash, afterwards someone asked me what I'd done to my rear bumper? I hadn't hit anything. When I looked, I was shocked. About 15" of the silver trimwork was torn off, still attached. Today I had the muffler replaced at Midas here in Toledo( (at a considerable cost) I asked the manager to look at the damage and told him it wasn't there until after the carwash. He said that the heat from the hole in the muffler had melted the bumper enough so that the brushes in the carwash were able to catch the edge and pull it off. Why is the muffler positioned SO CLOSE to the bumper? Tomorrow(11/18) I will visit the Taylor Kia Dealership(where I purchased the Telluride in 2020. Can there be a recall? …
When opening the sunroof (it opens with the press of a button, a part flew off of the sunroof and it came off of the tracks). After, we could not close it and it made a loud noise when pressing the button. We took it to Kia who said it needed a part that was back ordered. They put plastic over the roof and told my husband it was ok to drive it home. We assumed they had secured the sunroof as they kept the car for several hours. On the Highway, the entire sunroof flew off of the car landing in the middle of a 6 lane interstate. I've since read that other owners of kia tellurides have had failed sunroofs as well. Thankfully no cars were hit when our sunroof flew off but the risk was there. This is a safety issue that needs to be investigated. If the failed part is backordered, that could indicate that there may be a big demand for the part because it is failing.
Several oil housing changes. I'm not the first owner, the oil housing has been changed once already and I'm going to have to do it a second time, the car is only 5 years old. I've only owned the vehicle 2 years. The dealership did no diligence to check it, I went to the dealership for years and due to negligence with my oil changes and recalls I stopped going, now I'm having to pay out of pocket for issues they've caused. I thought I messed up my car and had a part dragging at the bottom, when I took it in to the dealership they said it was previously not bolted down properly. I had a recall, I was told 3 times my lights were connected and I was "good to go" each time I got in and the car said my lights were not connected. After this I never came back! Not sure if it's the dealership issue or on the car for my oil housing leak.
Tonight I tried to open my sunroof for some fresh air while relaxing in my vehicle. My sunroof made some weird cracking noises and is jammed open. I only used my sunroof 2 to 3 times. However, it's in the stuck position and sounds like crushing glass when I try to open it. My rear right passenger folds down on its own. My grandson has been folded into the seat multiple times. I contact kia and got no resolution. This is dangerous. I went to retrieve my backpack from my backseat yesterday and when I set the sear back it made a auto sound, it slid completely forward hitting me in my face. The seat ejects by itself often and it a safety risk to my family and i. I checked kia forums only to find this is an huge issue and spoked about hundreds of times involving telluride and Sorento models. I'm afraid my sunroof glass with break.
In March of 2025 I noticed that my Kia Telluride had a quarter size piece of paint missing in the middle of the roof near my windshield. As the past year has progressed paint delamination has occurred across the roof of my vehicle with other delamination spots being noticed in other areas of the body. My vehicle is a 2020 with 66,000 miles and is a white pearlescent coat. The delamination is exposing the body of my vehicle to the elements, causing rust and deterioration at a rapid speed. With a simple hand washing, the paint peeled off of my roof in a large area. This should not be occurring with a vehicle that has been well taken care of and should have many years of life left. Kia should be held responsible for the delamination that is occurring widely with the white pearlescent paint color.
Body complaints in other Telluride years
Frequently asked questions
How common are body problems on the 2020 Kia Telluride?
NHTSA has 56 complaints about the body & structure of the 2020 Kia Telluride, 7% of the model year's 776 complaints. The component named most often is body (54 mentions).
Is there a recall for 2020 Kia Telluride body problems?
No. NHTSA lists no body & structure recall for the 2020 Kia Telluride, though it has 7 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2020 Kia Telluride body problems start?
Half of the complaints with a recorded mileage happened before about 6,000 miles, and 75% before 25,000 miles.
Is it dangerous?
Owners linked 0 crashes, 0 fires and 2 injuries to body & structure problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.