Most common 2016 Kia Rio problems
Share of the 78 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Kia Rio complaints by model year
Best Rio years: 2011, 2022, 2010. Years to avoid: 2013, 2016, 2001, 2002, 2003. Compare all years →
2016 Kia Rio recalls (2)
Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge.
Latches/locks/linkages › Trunk lid › Latch
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside.
Remedy: Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2016 Kia Rio:
Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando.
What 2016 Kia Rio owners say
Engine & cooling all 42 →
On June 29, 2022, I was driving on I-5 southbound when I heard a loud sort of tapping sound coming from my engine. About 30 minutes later, before I had time to get to a gas station, there was a loud "BOOM!" sound and all of a sudden, the catalytic converter light and some other dash lights started to flash and I started to lose power. I pulled over to the left shoulder of the highway and before I could even pop the hood, I noticed flames immediately licking from the underside of the hood. I grabbed my phone and pulled my rabbit in her cage from the back seat of the car and called 911. My car continued to burn, starting a small brush fire, until the fire department finally came and put the fire out. The whole front of my car was completely incinerated and it had made its way to the back hatch in less than hour. …
The contact owns a 2016 Kia Rio. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact stated that the vehicle had an abnormal burning oil odor in the cabin of the vehicle. The contact drove the vehicle to an independent mechanic who checked the vehicle and determined that the spark plugs needed to be replaced. The vehicle was repaired. The contact stated that the check engine warning light illuminated again. The contact drove the vehicle back to another independent mechanic who checked the engine and determined that engine oil needed to be added. The vehicle was repaired. The mechanic informed the contact to check the oil level every week. The contact stated was adding a quart or more of engine oil every two weeks. The manufacturer was informed of the failure. The failure mileage was approximately 110,000.
Brakes
The contact owns a 2016 Kia RIO LX . The contact stated while driving 15 MPH, the contact could not see and it was difficult to steer the wheel causing the vehicle to slide into a ditch. The contact stated the Tire Pressure Monitoring System and Anti-lock Brake light was illuminated. The contact was able to drive the vehicle out of the ditch to the residence and later to the dealer. There was no physical injuries, however the contact sustain emotional trauma. The police was not called. The dealer stated the Steering Angle Sensor had a dtc1259 code . The vehicle was repaired, replacing the subframe and the control driver front lower control arm. The manufacturer was not made aware of the issue yet. The approximate failure mileage was 45,000.
The contact owns a 2016 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed or repaired. The approximate failure mileage was 60,000. VIN tool confirms parts not available.
Electrical system
While driving at highway speeds, the vehicle suddenly began bucking, lost power, and lost oil. The engine compartment immediately caught fire. The fire was entirely non-collision related and required immediate extinguishing. The incident was logged by the Washington State Patrol. The vehicle was towed and subsequently inspected by a certified Kia dealership. The Kia dealership technicians officially diagnosed the cause of the fire as a catastrophic internal engine failure, specifically noting in writing that they "found hole in engine block." They noted there was no other possible causation. This spontaneous engine failure and resulting fire occurred at approximately 99,000 miles. The vehicle is currently disabled and available for inspection upon request.
The contact owns a 2016 Kia Rio. The contact stated that occasionally the key failed to be removed from the ignition switch, and the front driver's side door. The contact stated no warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 49,000.
2016 Kia Rio engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.6L 4-cyl | 6-speed automatic | FWD | 27 / 36 / 31 |
| 1.6L 4-cyl | 6-speed manual | FWD | 27 / 36 / 31 |
EPA ratings. Class: Compact car.
Frequently asked questions
Is the 2016 Kia Rio a good car?
Based on 78 owner complaints filed with NHTSA, the 2016 Rio rates use caution: 1.9× as many complaints as a typical year of the Rio at the same age. It is one of the Rio years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2016 Kia Rio?
The engine & cooling — 42 complaints, 54% of all complaints for this model year. Next are the brakes (18) and electrical system (9).
How many recalls does the 2016 Kia Rio have?
There are 2 recalls for the 2016 Kia Rio, the most recent from September 25, 2023 (control unit/module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Kia Rio?
The best years by complaints, compared at the same age, are 2011, 2022 and 2010. Years to avoid or approach with caution: 2013, 2016, 2001, 2002 and 2003. See the full Kia Rio years comparison.
At what mileage do 2016 Kia Rio problems happen?
The median mileage reported in complaints is about 51,000 miles; 45% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.