Which parts fail
Components named in complaints (battery, alternator, wiring, ignition, instrument cluster, infotainment).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2023 Kia EV6 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2023 Kia EV6. The contact stated that the controls for the heating and cooling system on the steering wheel were too close and were a distraction. The contact stated that sunlight made it difficult to check the controls. While checking the features, the contact veered off the road. The contact stated that his hands lightly touched the controls, and he was unable to determine if the features were activated for the heated seats or the steering wheel. The contact stated that the controls needed to be less sensitive. The seats and steering wheel became hot. There were no warning lights illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The dealer referred the contact to the manufacturer. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 4,000.
The contact owns a 2023 Kia Ev6. The contact stated while driving at an undisclosed speed, the vehicle became inoperable. The vehicle was towed to a local dealer where the battery was replaced. The contact stated that the failure persisted, and the battery had been replaced approximately four times. The local dealer was able to diagnose the vehicle and related the failure to NHTSA Campaign Number: 24V200000 (Electrical System); however, the part to do the recall repair was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 8,000. Parts distribution disconnect.
The contact owns a 2023 Kia EV6. The contact stated while attempting to unlock the driver's side door with the remote, the door failed to unlock. The contact manually unlocked the door with the key. In addition, while attempting to start the vehicle, the vehicle failed to start, with the message "12-Volt battery failure" displayed. The vehicle was towed to a local dealer; however, the vehicle was not diagnosed. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V200000 (ELECTRICAL SYSTEM); as a probable cause for failure. The manufacturer was notified of the failure. The approximate failure mileage was 30,000.
The contact owns a 2023 Kia EV6. The vehicle was parked and turned off when the contact opened the door and smelled burned rubber and noticed a hole about inch deep in the front driver's seat the size of a nickel. The contact stated that the USB charging port on the vehicle was still active and caused the USB cable to catch on fire. The vehicle was taken to the dealer to be diagnosed; however, the dealer was unwilling to repair. The dealer did not believe that the failure was due to an electrical malfunction. The manufacturer was not made aware of the failure. The approximate failure mileage was 4,000.
The contact owns a 2023 Kia EV6. The contact stated that the horn button had failed to operate on several occasions without warning. Despite the failure, the contact stated that the panic button located on the key fob would sound the horn once depressed. The dealer was notified of the failure and informed the contact that the vehicle needed to be left with the dealer to have the vehicle inspected at the earliest availability. The manufacturer was also notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was 18,366.
When using 1 pedal driving, it isn't necessary to use the brake pedal to stop the EV. The EV6 will only illuminate the brake lights when the accelerator pedal is completely released, or when the brake pedal is depressed. Since using 1 pedal driving does not require depressing the brake pedal to stop, the following vehicle has no indication or warning that the EV6 is stopping. I have experienced several instances of near rear-end collisions because of this dangerous issue with the Kia EV6. I emailed Kia asking if they were going to offer an OTA fix and this is their reply, " Dear [redacted], Hello, This email is to let you know that as of now we are not aware of any updates coming out for this feature. Your complaint will remain on file here within Kia for review. Sincerely, Kia America. …
Hello NHTSA, I hope this message finds you well. I would like to provide specific details regarding the issues with my car as per your guidelines: 1. **Failed Component or System:** The charging system has malfunctioned, leading to extreme range decrease, constant charging failures, inconsistent charging speeds, and signs of overheating. The charging system warning light is on. 2. **Availability for Inspection:** The malfunctioned charging system and associated components are available for inspection upon request. 3. **Safety Risk:** The safety of myself and others is at risk due to the potential for unexpected vehicle breakdowns, especially during charging, and the indication of overheating poses an additional safety concern. 4. …
I purchased my 2023 Kia EV6 in December 28, 2024. On January 8, 2025, I took my EV6 in for the SC327 recall service. Despite completion of the recall service, my ICCU still failed and my car lost power while driving on February 6, 2025. I was driving 45 mph down a state road and was about to get into a highway onramp when my speed quickly dropped to 13 mph and my car displayed a "check electrical system" warning. The car would not go above 13 mph. I was fortunate that no one was following close behind me and that I was not on the highway. Had I been in front of a truck or other vehicle that couldn't stop quickly, the sudden deceleration could have been very dangerous. I was fortunate that I was near a parking lot that I could pull into to wait for a tow truck. By the time I got into the parking lot my car completely died and I was stuck without heat in 19 degree F weather. …
On April 6, 2025, while charging my car my Juicebox tripped a breaker. When I reset it the Juicebox was showing errors and was inoperable. I tried to use my backup charger (Blink) but it tripped a breaker and became inoperable too. I took the car a commercial charger (ChargePoint) and it would not charge the car. Kept getting a "charge interrupted" message. The first Kia dealer I went to did not have a Level 2 charger and could find nothing wrong and refused to help repair the car. The second Kia dealer had a Level 2 and confirmed it would not charge, but Kia would not authorize a warranty fix. That dealer suggested leaving the car for a few days and hope the car generates a fault that Kia will accept to authorize a fix. What component or system failed or malfunctioned, and is it available for inspection upon request? The Level 2 AC charging no longer works. …
On several occasions, when traveling over 55mph, once the battery hits a certain threshold (35% or 55% so far) the "power is limited" warning will appear on the dash and the vehicle will lose power. This has not occurred at lower speeds but only at higher speeds, and not every time. This vehicle was purchased so my husband could do his freeway commute, but it is on a remote highway where there is often no shoulder, so it especially dangerous to suddenly lose power with limited ability to safely pull over. On one such occasion, he drove the vehicle straight to Kia for inspection. They said the soonest available appointment was in 2 weeks and because they had no technicians available, they could not run the diagnostic that would allow us to get a rental car in the meantime. They suggested going to a different Kia dealership. …
Related recalls
Electrical system › Propulsion system › Traction battery
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge.
Electrical system › Propulsion system › Charging › Module › Software
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge.
Electrical system › 12V/24V/48V battery
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge.
Electrical complaints in other EV6 years
Frequently asked questions
How common are electrical problems on the 2023 Kia EV6?
NHTSA has 103 complaints about the electrical system of the 2023 Kia EV6, 75% of the model year's 137 complaints. The component named most often is wiring › connectors/plugs › accesory power outlet/jack/port/usb/sae/cigarette lighter (1 mentions).
Is there a recall for 2023 Kia EV6 electrical problems?
Yes — NHTSA recall 26V-431 (traction battery, Jul 2, 2026); NHTSA recall 24V-867 (software, Nov 18, 2024); NHTSA recall 24V-200 (12v/24v/48v battery, Mar 14, 2024). Recall repairs are free at authorized dealers.
At what mileage do 2023 Kia EV6 electrical problems start?
Half of the complaints with a recorded mileage happened before about 8,000 miles, and 80% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.