Which parts fail
Components named in complaints (struts, shocks, control arms, ball joints, springs).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2003 Honda Element owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2003 Honda Element. The contact stated that while his daughter was driving at approximately 25 MPH, the rear driver's side tire detached from the vehicle. Despite the failure, the contact's daughter managed to drive the vehicle to the residence. Upon inspection, the contact discovered that the rear trailing arm had detached from the vehicle. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 200,000. The VIN was not available.
The contact owns a 2003 Honda Element. The contact stated that while the contact's wife was driving at an undisclosed speed, the trailing arm fractured. In addition, the rear of the vehicle dropped to the ground and the driver's rear side of the vehicle was dragging on the ground. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000.
in 2023 while driving my 2003 Honda Element the control arm ripped out of the frame I had it fixed to the tune of $1800. Fast forward to this week when servicing my Element I found a major rust spot on the other trailing arm bracket. After more research there is a recall in Canada to fix this but not in US. how can this be? It is a major flaw and concern that at high speeds the arm can rip out. Honda has a fix, but it is not offered in the US. please help!
The contact owns a 2003 Honda Element. The contact stated that upon inspecting the vehicle, the independent mechanic informed him that the trailing arm mount was corroded, and that the subframe needed to be replaced. The mechanic advised the contact that the vehicle was unsafe to drive. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure. The failure mileage was approximately 140,000.
The car was being driven at a low speed across a school parking lot when there was a loud bang, the car dropped in the back and stopped movong. The rear trailing arm came apart from the body causing it to be inoperable. If I the car wasn't in a school zone and traveling at a high rate of speed this could have been a very serious accident. If there was a vehicle behind they would have rear ended the honda. If this happens on going down a hill it would have rolled over. If this happened on a busy highway it would have caused a multi car accident. Honda is aware of this issue in Canada but has done nothing to address it here in the United States. The vehicle is available for inspection for now. I can't have a vehicle sitting in my driveway that's inoperable due to city codes. The safety of the driver, passengers, pedestrians walking and other vehicles on the road are in danger. …
I turned onto Davie Blvd from SE 32nd heading West. I heard a "pop" & suddenly car was out of control-feeling like sliding. I pulled off to side street as I thought flat tire due to "pop" noise. All tires seemed fine so tried to drive again slowly but still felt no control/sliding effect. I slowly drove on side road watching back driver tire when I noticed it was facing outward as I steered straight. I learned from tow driver the sway bar/support snapped off from frame. I had car towed to where I was staying & researched on internet and was shocked to see many other Honda elements with same exact issue - and recall but now I see no recall (only in Canada where his Honda was repaired at no cost to him just in April of 2021 for 2003 Honda Element. I am upset as this was suppose to be my long term car after I had invested over $1700.00 just in past months to assure long future use. …
Same as the recalls for Honda ELEMENT of Canada and American Honda CRV of America In Honda's words: SUMMARY: American Honda Motor Co., Inc. (Honda) is recalling certain 2007-2011 model year CR-V vehicles. In salt-belt states where de-icing agents are used to maintain the roadway, the de-icing agents, along with mud and water, could enter the rear frame through drainage/positioning holes when the vehicle is driven through flooded areas or puddles at high speeds. Over time, the accumulated de-icing agents/mud/water mixture could cause corrosion to the frame's internal structure. If this occurs, the rear trailing arm can fall off. SAFETY RISK: The corrosion to the frame's internal structure can cause the rear trailing arm to fall off, increasing the risk of a crash or injury.
Vehicle has extreme corrosion of the frame near the rear trailing arm which is nearing catastrophic failure. Trailing arm is in danger of separating from the frame. This is similar to NTSB Campaign # 23V-22800 for the CR-V which shares suspension parts with the Element on these model years. If the trailing arm separates at highway speeds it could be fatal. This is a pre-emptive report of failure/loss, as I just attempted to jack up my vehicle on the drivers' side in the rear and had a great deal of the rusted frame detach near the point of the trailing arm attachment. I fear that it won't be long before the rest of the frame rusts through and if this occurs, that it may occur at highway speed and cause injury or death.
Inspection of the underbody revealed complete rusting away of the frame mount point for the passenger side lower control arm. The mounting has not failed yet, but the metal surrounding the bolt point is no longer providing any structure. I would not ordinarily have thought inform the NHTSA of this failure, but Internet searching has turned up many other owners of Elements experiencing this same failure and Honda has issued a recall in Canada for Elements for this problem. CR-Vs in the US that use the same chassis have had a recall for the same problem. Why has the recall not been extended to US Elements that are exposed to road salt? I have not yet contacted Honda regarding this issue.
My 2003 has severe rust around undercarriage mainly in the rear. The rear frame is corroded causing my drivers side trailing arm to come loose while driving on the highway. I almost lost control as the rear started to fishtail. Luckily I had no vehicles next to me which would have caused a major accident. I've done research and they do have the recall in Canada but not here in the USA. Honda should immediately have that recall before someone gets seriously hurt or even worse!
Suspension complaints in other Element years
Frequently asked questions
How common are suspension problems on the 2003 Honda Element?
NHTSA has 25 complaints about the suspension of the 2003 Honda Element, 6% of the model year's 423 complaints. The component named most often is rear (1 mentions).
Is there a recall for 2003 Honda Element suspension problems?
No. NHTSA lists no suspension recall for the 2003 Honda Element, though it has 10 recalls for other components. If the problem is widespread, a repair may still be covered by an extended warranty or a manufacturer service bulletin — ask a dealer.
At what mileage do 2003 Honda Element suspension problems start?
Half of the complaints with a recorded mileage happened before about 180,000 miles.
Is it dangerous?
Owners linked 3 crashes, 0 fires and 1 injury to suspension problems on this model year. If you notice symptoms, have the car checked before driving further.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.