Most common 2010 Dodge Caravan problems
Share of the 172 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Dodge Caravan complaints by model year
Best Caravan years: 2014, 2015, 2013. Years to avoid: 2005, 2000, 2008, 1996, 1997. Compare all years →
2010 Dodge Caravan recalls (2)
Suspension › Rear
The braun corporation is recalling certain model year 2008 through 2010 Chrysler town & country and Dodge caravan mobility conversions which were altered by braun between January 21, 2009 and March 19, 2010. During conversion, the chassis was raised and the floor was lowered to accommodate wheelchair accessibility features.
Remedy: Braun will notify owners and repair the vehicles free of charge. The safety recall began on June 4, 2010. Owners May contact braun toll-free at 1-800-488-0359.
Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap
The braun corporation is recalling certain model year 2008 through 2010 Chrysler town & country and Dodge caravan commercial entervans which were altered by braun between January 21, 2009 and March 19, 2010. During conversion, the chassis was raised and the floor was lowered to accommodate wheelchair accessibility features.
Remedy: Braun will notify owners and repair the vehicles free of charge. The safety recall began on June 4, 2010. Owners May contact braun toll-free at 1-800-488-0359.
NHTSA defect investigations
Federal safety investigators have looked into a possible defect involving the 2010 Dodge Caravan:
Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year.
What 2010 Dodge Caravan owners say
Electrical system all 79 →
There is a recall on the rear quarter window switch that May overheat . I received the letter on Thursday and by Sunday my door caught on fire, now not only the switch must be replaced and I suppose all wiring and rest of the switches and the door interior panel should be change because of damage. I called the recall center and after two days I'm still waiting for a call with instructions as to what to do not to mention the scare me and my wife got and the expenses it will cost me because I need to rent a car until the issue is resolved.
TIPM electrical fire while van was parked. Started after pushing the door lock on my key fob. Chrysler sent an independent adjuster out on 2/2/16. Have not heard from Chrysler yet. This is the 2nd time my van has had an electrical fire. 1st time was October 2014 - had to replace entire electrical system in the van. I saved the 2 boxes worth of burned harnesses/parts just in case. I paid $6,000 out of pocket last time. Fire department came and disconnected battery and fuse box. No flames or injuries.
Engine & cooling all 35 →
Original owner of the vehicle. This is actually a report of 5-6 separate incidents of the same issue within a week's span. The engine of the vehicle suddenly shuts off while driving. It is instant and silent, with no pre-warning. Driver loses all power steering / brakes during the occurrence. Last incident almost caused an accident when the vehicle's engine stalled and a following vehicle had to take action to avoid a collision. My wife and kids were in the van at the time of the incident. When it happens, the van always starts back up, but it has to be stationary and in-park. Vehicle was taken to the dealership on 01/23/15 for repair. Dealership indicated the EGR valve and temperature sensor was faulty and has been a common problem for decades. This is the second temperature sensor that has been replaced by the dealer. …
Vehicle shuts off while in motion usually within first 10 minutes of driving. We thought it was doing it because we did not warm up the engine enough in winter but now it happens is warmer weather as well. The engine just shuts off usually within .25-2 miles from the start of the trip. There is no engine check light, and no error in log. The car has already undergone the ignition key recall repair and a 3 day diagnostic at a local Dodge dealer in schaumburg il, without them finding anything wrong. This is very dangerous as the driver looses power steering, 2 times we almost got into an accident because the car stalled mid turn. It will stall while driving straight or turning. Usually of we let the car sit and warming up for 15-20 minutes the problem will not show up, but if we start the car and put it in drive within 1 minute it will most likely stall during the drive. …
Brakes all 23 →
My husband and I were driving one day, out of thy blue, the van began to shake towards the front of the van. We couldn't get the speed over 25 MPH. We got it to the nearest mechanic shop. They said it was the calipers. They said that it was very close to catching on fire. I had to have both calipers replaced and a brake job. I also had to purchase a new tire. I called and reported it to Dodge/Chrysler. They said that there had not been any problems with other vans. It was an extremely scary incident to go through. They said that they might be able to do something if the van had actually caught on fire. That's just crazy. This has cost me about $800.00. I just want to make sure that this gets reported in case other vans have similar problems. The mechanics were shocked at what they saw. They said that it should not have done what it did.
While driving one day, out of the blue my can would not go over 25 to 30 MPH. It would shake violently if we went faster. We got it to the mechanic and the brakes had almost caught on fire. It ruined one tire and the brakes and calipers. The mechanic said that this should have never happened. It was extremely dangerous. I reported it to Dodge. They said it had never happened. I want to make sure that it does get reported. I feel like I should be compensated for this. They said that there was nothing they could do since it never actually caught on fire. Really?
2010 Dodge Caravan engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 4.0L 6-cyl | 6-speed automatic | FWD | 17 / 25 / 20 |
| 3.3L 6-cyl | 4-speed automatic | FWD | 17 / 24 / 19 |
| 3.8L 6-cyl | 6-speed automatic | FWD | 16 / 23 / 18 |
EPA ratings. Class: Minivan.
Frequently asked questions
Is the 2010 Dodge Caravan a good car?
Based on 172 owner complaints filed with NHTSA, the 2010 Caravan rates average: 13% fewer complaints than a typical year of the Caravan at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2010 Dodge Caravan?
The electrical system — 79 complaints, 46% of all complaints for this model year, most often about ignition. Next are the engine & cooling (35) and brakes (23).
How many recalls does the 2010 Dodge Caravan have?
There are 2 recalls for the 2010 Dodge Caravan, the most recent from April 23, 2010 (rear). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Dodge Caravan?
The best years by complaints, compared at the same age, are 2014, 2015 and 2013. Years to avoid or approach with caution: 2005, 2000, 2008, 1996 and 1997. See the full Dodge Caravan years comparison.
At what mileage do 2010 Dodge Caravan problems happen?
The median mileage reported in complaints is about 52,000 miles; 45% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.