Most common 2013 Chevrolet Volt problems
Share of the 308 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Volt complaints by model year
Best Volt years: 2011, 2015, 2019. Years to avoid: 2017, 2013, 2018, 2012. Compare all years →
2013 Chevrolet Volt recalls (3)
Air bags › Frontal › Driver side › Inflator module
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023.
Hybrid propulsion system
General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Remedy: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.
Electrical system › Ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015.
NHTSA defect investigations
Federal safety investigators have looked into 2 possible defects involving the 2013 Chevrolet Volt:
Passenger Sensing System
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles.
What 2013 Chevrolet Volt owners say
Air bags all 161 →
The contact owns a 2013 Chevrolet Volt. The contact stated upon starting the vehicle, the air bag message "Service Air Bag" and the air bag warning light was illuminated on the instrument panel. The vehicle was taken to the dealer who diagnosed that the passenger's side seat air bag sensor had failed and needed to be replaced. The manufacturer was notified of the failure and advised the contact that they could not assist as his VIN was not included in a recall related to the failure. The vehicle was not repaired. The approximate failure mileage was 150,000.
I filed a complaint in 2019, it prompted an investigation. NHTSA Action Number: PE19013 I had not heard back from NHTSA or GM so I searched the NHTSA website and found that an agreement was made to close the investigation, in part because GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as: 1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation." When I attempted to have my vehicle repaired, the dealership didn't know what I was talking about. I contacted GM headquarters to inquire about the cost reduction program and I was told that they would look into it and get back with me. They denied me, they outright lied to NHTSA to close the investigation. …
Electrical system all 63 →
The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The Check Engine warning light was flashing, and the messages "No Propulsion Power" and "No Power To Engine" were displayed. The contact stated that two individuals pulled over and assisted the contact in pushing the vehicle to the side of the road to prevent a crash. The vehicle was towed to an independent mechanic, who made the contact aware of an unknown NHTSA Campaign Number; however, the VIN was not included. The vehicle was towed to a dealer, but the vehicle was not diagnosed or repaired. The contact requested vehicle rental assistance, but the dealer was unable to provide assistance. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance in initiating a recall. The failure mileage was approximately 141,323.
The contact owns a 2013 Chevrolet Volt. The contact stated while driving approximately 76-77 MPH, the vehicle experienced reduced power. The message "Low Propulsion" was displayed, and the engine revved significantly. The contact moved over to the far-right lane to pull over to the side of the road as needed. The contact stated that the failure had been recurring temporarily. The contact had researched the failure online and became aware that the release of the accelerator pedal while the failure was occurring could temporarily correct the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 61,000.
Fuel & propulsion system all 57 →
The contact owns a 2013 Chevrolet Volt. The contact stated while driving approximately 76-77 MPH, the vehicle experienced reduced power. The message "Low Propulsion" was displayed, and the engine revved significantly. The contact moved over to the far-right lane to pull over to the side of the road as needed. The contact stated that the failure had been recurring temporarily. The contact had researched the failure online and became aware that the release of the accelerator pedal while the failure was occurring could temporarily correct the failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 61,000.
The contact owns a 2013 Chevrolet Volt. The contact stated while driving 50 MPH, the vehicle lost motive power with the check engine warning light and low oil pressure warning light illuminated. The vehicle was towed to the dealer where a diagnostic test result was undisclosed; however, the contact was informed that the vehicle needed an ASC high-voltage battery to be replaced. The vehicle was not repaired after the ASC battery was replaced. The contact stated that the propulsion system warning light was illuminated. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
2013 Chevrolet Volt engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.4L 4-cyl plug-in hybrid | CVT | FWD | 35 / 40 / 37 |
EPA ratings. Class: Compact car.
Frequently asked questions
Is the 2013 Chevrolet Volt a good car?
Based on 308 owner complaints filed with NHTSA, the 2013 Volt rates avoid: 2.2× as many complaints as a typical year of the Volt at the same age. It is one of the Volt years we suggest avoiding. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2013 Chevrolet Volt?
The air bags — 161 complaints, 52% of all complaints for this model year, most often about frontal › sensor/control module. Next are the electrical system (63) and fuel & propulsion system (57).
How many recalls does the 2013 Chevrolet Volt have?
There are 3 recalls for the 2013 Chevrolet Volt, the most recent from July 27, 2023 (inflator module). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chevrolet Volt?
The best years by complaints, compared at the same age, are 2011, 2015 and 2019. Years to avoid or approach with caution: 2017, 2013, 2018 and 2012. See the full Chevrolet Volt years comparison.
At what mileage do 2013 Chevrolet Volt problems happen?
The median mileage reported in complaints is about 67,000 miles; 31% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.