Most common 2007 Chevrolet Aveo problems
Share of the 216 complaints; one complaint can involve more than one system. "~" is the median mileage when the problem started.
Chevrolet Aveo complaints by model year
Best Aveo years: 2010, 2011. Compare all years →
2007 Chevrolet Aveo recalls (2)
Exterior lighting › Headlights
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014.
Fuel system, gasoline
On certain passenger vehicles equipped with a 1.6l engine, during a ncap severe frontal crash test, the fuel line in the engine compartment developed a fracture. In addition, the crash damage caused four short circuits in the fuse block, the combination of which allowed the fuel pump to continue running and fuel leaked onto the…
Remedy: Dealers will replace the fuse block and install a new section of fuel line that has been redesigned free of charge. The recall began on November 16, 2006. Owners May contact Chevrolet at 1-800-630-2438.
What 2007 Chevrolet Aveo owners say
Air bags all 84 →
The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver's side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with the front driver's side air bag. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately of 52,000.
While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. …
Electrical system all 50 →
While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. …
I was driving to my mother's house, the car was not shifting right and the engine was whining, all of a sudden I smelled smoke and seen fire under the hood. GM would only fix the harness , the vehicle would start again but you could not drive it. No power in the engine. So I had to eat $6400.00 dollars I owed and traded it with carbone auto in yorkville new york. They sold me a car with the ABS lights on the traction lights on, the tire pressure lights come on and my doors lock and I have to climb over to the other seat to get out. The salesman knew these lights were on before I signed the papers and my car is still not fixed. This past winter I had no heat and got caught in an ice storm and my windows iced right over I could not see and hit a pole by my driveway and dented and scratch the whole right side of my car. It is carbone auto that made it so my Aveo caught fire. …
Lights all 32 →
While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. …
Tl* the contact owns a 2008 Chevrolet Aveo. The contact stated the seat belt warning light illuminated and the wires for the parking lights were burnt. The contact took the vehicle to an independent mechanic who replaced the vehicle's front light assembly. The dealer was not contacted. The manufacturer was not made aware of the failure. The contact stated that the failure was related to NHTSA campaign number: 14V261000 (exterior lighting) however, the VIN was not included. The approximate failure mileage was 120,000.
2007 Chevrolet Aveo engines & fuel economy
| Engine | Transmission | Drive | MPG city / hwy / combined |
|---|---|---|---|
| 1.6L 4-cyl | 5-speed manual | FWD | 23 / 33 / 27 |
| 1.6L 4-cyl | 4-speed automatic | FWD | 23 / 31 / 26 |
EPA ratings. Class: Subcompact car.
Frequently asked questions
Is the 2007 Chevrolet Aveo a good car?
Based on 216 owner complaints filed with NHTSA, the 2007 Aveo rates average: 1.2× as many complaints as a typical year of the Aveo at the same age. Complaint counts don't account for sales volume or individual maintenance, so have any used car inspected before buying.
What is the most common problem with the 2007 Chevrolet Aveo?
The air bags — 84 complaints, 39% of all complaints for this model year, most often about frontal. Next are the electrical system (50) and lights (32).
How many recalls does the 2007 Chevrolet Aveo have?
There are 2 recalls for the 2007 Chevrolet Aveo, the most recent from May 19, 2014 (headlights). Recall repairs are free at any authorized dealer — check whether yours has been done with the VIN recall check.
What are the best and worst years of the Chevrolet Aveo?
The best years by complaints, compared at the same age, are 2010 and 2011. See the full Chevrolet Aveo years comparison.
At what mileage do 2007 Chevrolet Aveo problems happen?
The median mileage reported in complaints is about 52,000 miles; 47% of problems with a recorded mileage started before 50,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.