Which parts fail
Components named in complaints (doors, hood, frame, rust, paint and trim).
Mileage when the problem started
Owner reports
Selected complaints filed with NHTSA by 2019 BMW X3 owners, lightly cleaned up (personal details are redacted by NHTSA).
The contact owns a 2019 BMW X3. The contact stated that upon starting the vehicle, the message "Emergency Call System Notification Failure" was displayed on the instrument cluster, causing the speedometer and the odometer to become inoperable. The service warning light was illuminated. Additionally, the contact stated that the navigation system was inoperable, and the vehicle function setting on the infotainment system also indicated that the Emergency Call System Notification had failed. The vehicle was taken to the dealer, where it was diagnosed that the TBC module and battery had failed due to water intrusion in the shark fin of the roof. The dealer determined that the TBC module and the TBC module battery needed to be replaced. Additionally, the dealer informed the contact that the shark fin needed to be resealed. The vehicle was not repaired due to the cost. …
The contact owns a 2019 BMW X3. The contact stated that after a rainstorm, water would leak through the Telematics Control Unit (TCU) located on the roof at the rear of the vehicle. The contact stated that the leak caused a short circuit of the TCU wiring harness. The contact stated that a warning for the "Emergency Call System" was illuminated. The contact stated that the message covered the instrument cluster. The contact was unable to see the speedometer or other gauges on the instrument cluster because the message could not be cleared due to the short circuit. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the TCU needed to be resealed and the wiring harness and transponder module needed to be replaced. The vehicle was repaired. …
The contact owns a 2019 BMW X3. The contact stated that the Navigation system had become inoperable. Additionally, the message "Emergency Call Malfunction" was displayed. The vehicle was taken to the dealer, where it was determined that the seal of the roof-mounted antenna housing had separated from the vehicle, causing water to leak into the antenna housing wiring and causing the electrical failures. The contact was charged a fee for the repair. The vehicle was not repaired due to the cost. The contact related the failure to Technical Service Bulletin Number: SIB 65 12 22. The manufacturer was notified of the failure and a case was opened. The contact was awaiting an email from the manufacturer. The failure mileage was approximately 85,000.
While driving our BMW 2019 X3 on the highway, other drivers honked to get my attention that our vehicle's rear hatch was partially open. When we came to a stop light, I had my son riding in the passenger seat press the hatch button on the key fob to close the hatch. Instead this fully opened the back hatch. We continued pressing the fob button in an attempt to get the hatch to close without having to exit the vehicle. Rather than exit the vechicle in the middle of the roadway, we drove about 50 yards until we could pull over safely. A motorcyclist had been following us, and came up behind and communicated that he wanted to press the button to close the hatch. After I gave my consent, he pressed the close button and the hatch closed and latched. My husband has previously had incidents where after parking the BMW, he finds the back hatch open. …
The seal of the roof-mounted antenna housing adhesive was faulty. This caused separating from the vehicle allowing water into the vehicle, which damaged emergency call components and equipment. BMW told me this was a know issue, but that NHTSA had not yet applied this to my vehicle. Please issue an advisory on this known issue. My car is under 40,000 miles and fairly new still. Adhesive should not be deteriorating this early. Preventative maintenance could not have addressed this factory issue. - Excerpt from BMW inspection: Concern Critical Client States Emergency Call Malfunction On. Aux Battery Replaced Twice. Ref Ro 871625 And Ro 907864. Please Check And Advise Cause FOUND SHARK FIN COVER GLUE TO BE LOOSE AND TO HAVE A SLOW WATER LEAK. WATER DAMAGED TCB MODULE. NO COMMUNICATION WITH TCB MODULE. Correction REPLACE TCB MODULE. REPLACE ROOF ANTENNA. REPLACE SHARK FIN. …
My 2019 BMW X3 posted this error on the instrument display "Emergency call system malfunction". BMW service informed me that the shark fin roof mounted antenna is leaking. It causes issues with the SOS feature, navigation (reporting wrong location). There are numerous complaints on BMW owners message boards with the same problem. There is at least one BMW Service Information Bulletin (SIB) that applies to this issue for my vehicle. It is number B65 12 22. I was told this issue is not covered under my certified pre-owned warranty. This is a safety issue affecting thousands of BMW owners. BMW should do the right thing, issue a recall on the affected models and repair this problem. Thank you.
On September 7, 2021, the tailgate of my 2019 BMW X3 opened on its own in my garage. The car had been turned off for approximately 20-25 minutes. My key was inside the house, nowhere near the garage. No one had touched the car after it was turned off. My husband was in the garage, standing approximately 6-10 feet away from the car when the tailgate opened on its own. I believe this is both a Safety and Security issue. The tailgate opened on its own. This could have occurred while driving on a highway (safety), or while parked on a public street (security).street. On 9/9/21 I reported the problem to Zach Santillo in the Service Dept of our dealer: BMW-Newton, NJ.
The contact owns a 2019 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2019 BMW X3. The contact received notification of NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2019 BMW X3. The contact discovered that the vehicle was included in NHTSA Campaign Number: 24V534000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Related recalls
Structure
BMW of North America, LLC (BMW) is recalling certain 2018-2022 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the rear cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Remedy: Dealers will replace the rear cargo rail attachment bolts, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Structure
BMW of North America, LLC (BMW) is recalling certain 2018-2023 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the interior cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Remedy: Dealers will replace the rear cargo rail attachment bolts, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Body complaints in other X3 years
Frequently asked questions
How common are body problems on the 2019 BMW X3?
NHTSA has 31 complaints about the body & structure of the 2019 BMW X3, 18% of the model year's 171 complaints. The component named most often is body (20 mentions).
Is there a recall for 2019 BMW X3 body problems?
Yes — NHTSA recall 24V-764 (structure, Oct 15, 2024); NHTSA recall 24V-534 (structure, Jul 17, 2024). Recall repairs are free at authorized dealers.
At what mileage do 2019 BMW X3 body problems start?
Half of the complaints with a recorded mileage happened before about 5,000 miles, and 79% before 25,000 miles.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) — owner complaints through October 20, 2026, recalls and defect investigations; fuel economy from the EPA. Complaints are unverified reports and are not proof of a defect. How we rate model years.